2005 HONDA CR-V Recalls Canada & USA – Major League Recalls
2005 HONDA CR-V Recalls — Canada & USA
Summary
The 2005 Honda CR-V has 4 recalls, the most serious being a driver-side power window switch that can overheat, smoke, and catch fire, even when the vehicle is parked and not in use.
Recalls 1 and 2 describe the same underlying issue: moisture gets into the window master switch and causes it to fail or melt, creating a fire risk. On the airbag side, a mispositioned sensor in the passenger occupant detection system may fail to shut off the side impact airbag when a passenger is out of position, meaning the airbag can deploy with enough force to injure someone sitting in an unexpected posture during a crash. There is also a headlight concern affecting 2005 model year vehicles: terminal ends inside the wiring harness connector can melt, causing the low-beam headlights to stop working and leaving the driver with reduced visibility at night.
Honda (American Honda Motor Co.) is recalling certain 2002-2006 CR-V vehicles. Moisture may enter the driver side power window master switch, causing the switch to fail or melt.
Safety Risk
If the switch fails, it could overheat and smoke, increasing the risk of a fire.
Remedy
Honda will notify owners, and dealers will replace the power window master switch and inspect the wiring harness for damage, replacing it if necessary, free of charge. The recall began January 29, 2021. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is P9D.
Honda is recalling certain model year 2002-2006 CR-V passenger vehicles, manufactured from February 19, 2002, through July 28, 2006. The driver-side power window switch may fail or melt.
Safety Risk
If the switch fails, it could overheat, smoke, and cause a fire. A switch failure, and a fire, could occur even if the vehicle is not in use. As a precaution, owners are advised to park outside until the recall repair has been performed.
Remedy
Honda will notify owners, and dealers will inspect and repair the switches, as necessary, free of charge. The safety recall began on November 2, 2012. Owners may contact Honda at 1-800-999-1009.
HONDA IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2004 CR-V; MODEL YEAR 2003 THROUGH 2005 PILOT; AND MODEL YEAR 2002 AND 2003 CIVIC VEHICLES. IN MARCH 2012, HONDA FILED A DEFECT REPORT TO RECALL CERTAIN MODEL YEAR 2002 THROUGH 2004 CR-V AND CERTAIN MODEL YEAR 2003 PILOT VEHICLES. IN AUGUST 2012, HONDA INFORMED THE AGENCY THAT IT WAS INCLUDING AN ADDITIONAL 820,789 VEHICLES INCLUDING CERTAIN MODEL YEAR 2004 AND 2005 PILOTS AND MODEL YEAR 2002 AND 2003 CIVICS. THE TOTAL NUMBER OF VEHICLES BEING RECALLED IS NOW 1,375,217. DUE TO TENSION FROM THE COMBINATION SWITCH WIRING HARNESS, WEAR ON THE SURFACE OF THE ELECTRICAL TERMINAL CAN OCCUR, YIELDING COPPER OXIDE, WHICH INCREASES ELECTRICAL RESISTANCE. INCREASED ELECTRICAL RESISTANCE MAY CAUSE THE TERMINAL ENDS TO MELT WITHIN THE WIRING HARNESS CONNECTOR.
Safety Risk
IF THE TERMINAL ENDS MELT WITHIN THE WIRING HARNESS CONNECTOR, THE LOW BEAM HEADLIGHTS MAY BECOME INOPERATIVE, REDUCING DRIVER VISIBILITY AND INCREASING THE RISK OF A CRASH.
Remedy
HONDA WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE LOW BEAM TERMINAL HARNESS OR REPLACE THE LIGHTING SWITCH AS NECESSARY, FREE OF CHARGE. THE ORIGINAL RECALL BEGAN IN APRIL 2012. OWNERS OF VEHICLES INVOLVED IN THE SEPTEMBER 2012 EXPANSION WILL BE NOTIFIED IN SEPTEMBER 2012. OWNERS MAY CONTACT HONDA CUSTOMER SERVICE AT 1-800-999-1009.
ON CERTAIN PASSENGER VEHICLES, THE OCCUPANT POSITION DETECTION SYSTEM'S SIDE SENSOR IS NOT INSTALLED IN THE CORRECT POSITION AND MAY FAIL TO SHUT OFF THE PASSENGER'S SIDE IMPACT AIRBAG IF THE OCCUPANT IS OUT-OF-POSITION.
Safety Risk
IN THE EVENT OF A CRASH, SUCH AN OUT-OF POSITION OCCUPANT MAY BE INJURED BY A DEPLOYING SIDE AIRBAG.
Remedy
DEALERS WILL REPLACE THE PASSENGER'S SEAT-BACK PAD WHICH INCUDES THE OCCUPANT POSITION DETECTION SYSTEM SENSOR. THE RECALL BEGAN ON ON NOVEMBER 19, 2004. OWNERS SHOULD CONTACT HONDA AT 1-800-999-1009.
