General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.
Safety Risk
If the DRL module melts due to the heat generation, it could cause a vehicle fire.
Remedy
GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet). General Motors recall number for this campaign is 14236.
Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2004-2008 Forenza vehicles, and 2005-2008 Reno vehicles manufactured from September 1, 2003, through July 30, 2008. In the affected vehicles, heat may be generated in the headlamp switch or daytime running light (DRL) module which could melt the headlamp switch or the DRL module.
Safety Risk
If the heat generated within the headlamp switch or DRL module located on the left side of the steering column melts the headlamp switch or DRL module, there is an increased risk of a fire.
Remedy
Suzuki will replace the signal switch and add a jumper relay kit and will replace the DRL Module in teh instrument panel harness. Suzuki distributed to owners an interim letter on July 30, 2014. The recall began October 29, 2014. Owners may contact Suzuki at 1-800-934-0934. Suzuki's number for this recall is XA.
General Motors LLC (GM) is recalling certain model year 2005-2007 Chevrolet Corvette vehicles manufactured March 29, 2004, through June 22, 2007. In the affected vehicles, the underhood bussed electrical center (UBEC) housing can expand and cause the headlamp low beam relay control circuit wire to bend. If the wire is repeatedly bent, it may fracture causing a loss of low beam headlamp illumination.
Safety Risk
The loss of low beam headlamp illumination will decrease the driver's visibility, as well as the vehicle's conspicuity to other motorists, increasing the risk of a crash.
Remedy
GM will notify owners, and dealers will install a jumper wire to correct this condition, free of charge. The recall began January 2, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 13146. Note: Model year 2008-2013 Chevrolet Corvettes will be covered under customer satisfaction program number 14203 for the same issue.
Volkswagen Group of America (Volkswagen) is recalling certain model year 2012-2013 Passat vehicles manufactured January 2011 through November 2012. In the affected vehicles, the low beam headlight bulb may become loose and lose electrical contact.
Safety Risk
A loss of low beam headlights may reduce the driver's visibility and increase the risk of a crash.
Remedy
Volkswagen notified owners, and dealers will replace the bulb holder, free of charge. The recall began in May 2014. Owners may contact Volkswagen at 1-800-822-8987. Volkswagens recall number associated with this campaign is 94G8/7V.
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2012 Dodge Charger vehicles manufactured May 20, 2010, through November 8, 2011, and equipped with halogen headlamps. In the affected vehicles, a sub-harness for the headlights may overheat and cause the low beam headlights to go out.
Safety Risk
Loss of headlights reduces the driver's visibility, increasing the risk of a crash.
Remedy
Chrysler will notify owners, and dealers will replace the headlamp jumper harnesses and bulbs, or the headlamp assemblies, as necessary, free of charge. The recall began on May 2, 2014. Owners may contract Chrysler at 1-800-853-1403. Chrysler's number associated with this recall is P08. This recall concerns non-police vehicles. A separate campaign was launched in 2012 to address police vehicles. See NHTSA recall 12V-042.
Yamaha Motor Corporation USA (Yamaha) is recalling certain model year 2009-2013 YZFR1 motorcycles manufactured October 2008 through August 2013 and 2012-2013 XTZ12 motorcycles manufactured October 2011 through August 2013. In the affected motorcycles, use of the headlight may generate enough heat to cause the bulb connections to expand, resulting in arcing in the headlight bulb socket which could cause the socket to overheat, melt and cause the headlight to malfunction.
Safety Risk
A headlight failure reduces the rider's ability to see clearly and the motorcycle's visibility to oncoming traffic, increasing the risk of a crash.
Remedy
Yamaha will notify owners and dealers will replace the headlight socket, free of charge. The recall began on March 10, 2014. Owners may contact Yamaha at 1-800-962-7926.
Chrysler is recalling certain model year 2013 Ram 2500 and 3500 trucks manufactured January 7, 2013, through February 28, 2013 and equipped with optional premium headlamps. The headlamp shutters may function improperly when in high-beam mode. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, reflective devices, and associated equipment."
Safety Risk
Improper headlight shutter function during high beam use may reduce the drivers visibility and possibly blind oncoming traffic. Either condition may increase the risk of crash.
Remedy
Chrysler will notify owners, and dealers will reconfigure the Central Body Controller, free of charge. The recall began July 30, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N33.
Lamborghini is recalling certain model year 2012 Aventador vehicles manufactured July 15, 2011, through April 20, 2012 for failing to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment." The affected vehicles may have headlights that can be aimed horizontally but not vertically.
Safety Risk
An incorrect headlamp aim could reduce the drivers visibility and possibly blind oncoming traffic. Either condition may increase the risk of crash.
Remedy
Lamborghini will notify owners, and dealers will enable the vertical aiming and disable the horizontal aiming of the headlights, free of charge. Owners may contact Lamborghini at 1-866-681-6276.
Ford is recalling certain model year 2013 Fusion vehicles, manufactured from February 3, 2012, through October 20, 2012, for failing to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment." The affected vehicles may not have had the low beam headlamp projector coating properly cured during its manufacturing process.
Safety Risk
An improperly cured projector coating will become hazy through operation, over time, reducing the brightness of the low-beam lamp. This may decrease driver visibility and increase the risk of a vehicle crash.
Remedy
Ford will notify owners, and dealers will replace the headlamp assembly. The recall began on December 18, 2012. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332.
Suzuki is recalling certain model year 2004-2006 Forenza and model year 2005-2006 Reno vehicles manufactured from September 23, 2003, through March 7, 2006. Increased resistance due to poor contact between the terminals of certain wires can generate heat that can melt the splice pack used to connect the power circuit wires for the headlamps. This can result in intermittent or total loss of low/high beam headlamp function.
Safety Risk
If the headlamps fail to function, this will lead to reduced driver visibility, increasing the risk of a crash.
Remedy
Suzuki will notify owners, and Suzuki dealers will reconnect the affected wires with two heat-shrink crimps, free of charge. The safety recall began on September 25, 2012. Owners may contact Suzuki at 1-877-697-8985.
PORSCHE IS RECALLING CERTAIN MODEL YEAR 2011-2012 CAYENNE, CAYENNE S, CAYENNE S HYBRID, AND CAYENNE TURBO VEHICLES MANUFACTURED FROM MARCH 8, 2010, THROUGH JANUARY 31, 2012 BECAUSE THE HEADLAMPS MAY COME LOOSE AND DETACH FROM THE FENDER.
Safety Risk
A DETACHED HEADLIGHT COULD LEAD TO LOSS OF VISIBILITY AND AN INCREASED RISK OF A CRASH.
Remedy
PORSCHE WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE HEADLAMP LOCKING ASSEMBLIES, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 9, 2012. OWNERS MAY CONTACT PORSCHE AT 1-800-767-7243.
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Safety Risk
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Safety Risk
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
Remedy
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Safety Risk
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
Remedy
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME VEHICLES MAY NOT HAVE HAD A REQUIRED CAP INSTALLED WHICH DISABLES THE HEADLIGHT HORIZONTAL AIM AND SOME VEHICLES MAY CONTAIN A CAP THAT DISABLES THE VERTICAL AIMING SCREW.
Safety Risk
NONCOMPLIANCE CAN INHIBIT PROPER HEADLAMP AIM ADJUSTMENT FOR ROADWAY ILLUMINATION, IMPROPERLY AIMED HEADLAMPS COULD CAUSE REDUCED ROAD VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE LOW BEAM HORIZONTAL AIMING SCREW AND INSTALL ONE IF MISSING, AND INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE VERTICAL AIMING SCREW AND IF PRESENT, THE CAP WILL BE REMOVED. THE RECALL WILL BEGIN ON OCTOBER 31, 2007. OWNERS MAY CONTACT VW AT 1-800-822-8987.
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Safety Risk
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
CERTAIN VEHICLES FAIL TO COMPLY WITH THE "VERTICAL GRADIENT" AND "HEADLAMP PHOTOMETRIC VALUES" REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, 'LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.'
Safety Risk
THIS STANDARD IS TO REDUCE CRASHES, INJURIES AND DEATHS BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY, AND BY ENHANCING THE CONSPICUITY OF MOTOR VEHICLES ON THE PUBLIC ROADS SO THAT THEIR PRESENCE IS PERCEIVED AND THEIR SIGNALS UNDERSTOOD, BOTH IN DAYLIGHT AND IN DARKNESS OR OTHER CONDITIONS OF REDUCED VISIBILITY.
Remedy
DEALERS WILL REPLACE THE HEADLAMP ASSEMBLIES. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT APRIL 16, 2007. OWNERS MAY CONTACT INFINITI AT 1-800-662-6200.
DURING A CANADIAN COMPLIANCE TEST, CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, 'LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.' THE HEADLAMP ASSEMBLIES DO NOT MEET THE HEADLAMP PHOTOMETRIC VALUES REQUIREMENTS OF THE STANDARD.
Safety Risk
THIS STANDARD IS TO REDUCE TRAFFIC ACCIDENTS AND DEATHS AND INJURIES RESULTING FROM TRAFFIC ACCIDENTS, BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY, AND BY ENHANCING THE CONSPICUITY OF MOTOR VEHICLES ON THE PUBLIC ROADS SO THAT THEIR PRESENCE IS PERCEIVED AND THEIR SIGNALS UNDERSTOOD, BOTH IN DAYLIGHT AND IN DARKNESS OR OTHER CONDITIONS OF REDUCED VISIBILITY.
Remedy
DEALERS WILL REPLACE THE HEADLAMP ASSEMBLIES. THE RECALL BEGAN ON DECEMBER 18, 2006. OWNERS MAY CONTACT INFINITI AT 1-800-662-6200.
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Safety Risk
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Safety Risk
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
