This page covers 4 recalls and 15 owner complaints for the 2010 Chevrolet Express.
For the 2010 Chevrolet Express, the most-reported complaints center on the airbag system. Owners describe side airbags deploying unexpectedly while driving at low speeds with no collision or prior damage to the vehicle. A separate report mentions a diagnostic code pointing to a faulty passenger-side airbag module. Engine and powertrain complaints are fewer but include at least one account of the vehicle revving and shaking violently on a downhill grade, with no fault found at the dealer. A handful of electrical complaints describe recurring tail light and turn signal failures, with the body control module replaced as part of one repair attempt. The complaint volume here is relatively low overall, so none of these patterns outside the airbag reports appears across a large number of filings.
15
Total Complaints
1
Crash-Related
1
Fire-Related
2
With Injuries
By System
The 2010 Chevrolet Express has 4 recalls, the most serious being a generator fault that can create a short circuit and generate enough heat to start an engine compartment fire.
On the mobility equipment side, certain conversion vans fitted with Braun wheelchair lifts have roll stop latches on the outer barrier that can bend or fall out of alignment over time, allowing a wheelchair occupant to roll past the barrier. There are also two equipment and visibility concerns: the HVAC control knobs can crack and spin freely on their shafts, which can leave the defroster unresponsive and reduce the driver's ability to see through the windshield. Some vehicles were also equipped with fire extinguishers that may fail to discharge properly when needed.
At a glance
What can fail
The fire extinguisher may clog and fail to discharge, or require excessive force to use. In some models, the nozzle may detach forcefully, potentially causing injury and making the extinguisher inoperable.
What the fix does
GM will provide a free replacement fire extinguisher from Kidde. Contact your vehicle manufacturer's customer service to arrange the replacement.
We may earn a commission for purchases made through these links.
Complaints are owner-reported and reflect individual experiences, not confirmed defects. They are distinct from recalls. Data sourced from the national vehicle safety complaint database. See trending complaints →
Summarized — see the official notice for exact wording, dates, and contacts.
At a glance
What can fail
The roll stop latches on the wheelchair lift's outer barrier may bend or misalign over time with frequent use, potentially affecting lift operation.
What the fix does
Braun dealers will repair the roll stop latches on the wheelchair lift at no charge to the owner.
Summarized — see the official notice for exact wording, dates, and contacts.
At a glance
What can fail
The voltage regulator inside the generator may develop an internal short circuit, causing low electrical resistance.
What the fix does
Dealers will inspect the generator and replace it if needed at no cost to you.
Summarized — see the official notice for exact wording, dates, and contacts.
At a glance
What can fail
The HVAC control knobs can crack and spin freely on their shaft, preventing the driver from adjusting heating, cooling, and ventilation.
What the fix does
All HVAC control knobs will be replaced at no charge by dealers.
Summarized — see the official notice for exact wording, dates, and contacts.
