NHTSA (USA)High Risk
At a glance
This page covers 5 recalls, 230 owner complaints, NHTSA crash-test ratings and EPA fuel economy for the 2019 Dodge Grand Caravan.
20 mpg combined
11.8 L/100km
Minivan - 2WD
Fuel economy data from fueleconomy.gov (EPA / U.S. Dept. of Energy). Annual cost based on 15,000 mi/yr at 55% city driving and current fuel prices. MPG is U.S. gallons; L/100km converted. Ranges reflect the 2 tested variants for this model year.
4/5 Overall
NHTSA 5-Star Safety Rating
Transmission problems dominate owner complaints for the 2019 Dodge Grand Caravan. Owners frequently report transmission slipping, grinding, shuddering, and in several cases outright failure, some describing the vehicle stalling at stops or needing to be towed. Torque converter issues come up repeatedly, with some owners noting the vehicle stalls when stopping in traffic and requires a manual workaround like shifting to neutral to keep it running. Electrical complaints are the second most common category, covering a wide range of issues including sliding doors that won't open or lock properly, window operation problems, and alarms triggering without a clear cause. Engine problems round out the top three, though at a lower volume. The sliding door system draws particular attention in the electrical complaints, with owners describing doors that respond slowly, fail to latch, or require a battery disconnect to reset the alarm.
230
Total Complaints
6
Crash-Related
3
Fire-Related
15
With Injuries
By System
The 2019 Dodge Grand Caravan has 5 recalls, the most serious affecting Vantage-modified vehicles where a deteriorating fuel pump gasket can leak fuel and create a fire risk near any ignition source.
Two recalls address seat striker welds on the second and third row seats. In one, the striker welds on the second and third row seats may not be properly attached, meaning a seat or seatbelt can move or pull free in a crash rather than holding the occupant in place. A separate recall covers a similar problem specific to the second row bench and bucket seat outboard strikers, which can fail in a front impact, and the third row bench seat front outboard strikers, which can fail in a rear impact. In both cases, the seat loses its anchor point and the seatbelt attached to it can no longer restrain the occupant properly. Prior repair attempts did not fully resolve the issue across all affected vehicles.
On the braking side, the rear brake calipers on certain vehicles may develop gas pockets inside the piston coating, which reduces the clamping force the caliper can apply to the rotor. The driver may notice longer stopping distances or a soft pedal feel, and braking performance can fall short in an emergency stop.
There is also a recall affecting vehicles equipped with QRT-Deluxe or QRT-Max wheelchair restraints installed by Rollx Vans. The restraint system can fail to hold a wheelchair securely, allowing it to shift or roll during transit and putting the occupant at risk of injury.
At a glance
We may earn a commission for purchases made through these links.
Ratings from NHTSA's New Car Assessment Program (NCAP). Based on 2 tested variants; worst-case ratings shown.
Complaints are owner-reported and reflect individual experiences, not confirmed defects. They are distinct from recalls. Data sourced from the national vehicle safety complaint database. See trending complaints →
What can fail
The wheelchair restraint retractors may fail to lock, leaving wheelchairs unsecured in the vehicle.
What the fix does
Rollx will inspect and replace the retractors at no cost. Contact Rollx customer service at 1-800-956-6668.
Summarized — see the official notice for exact wording, dates, and contacts.
At a glance
What can fail
The fuel pump gasket can wear down over time, which may cause fuel to leak from the tank.
What the fix does
Vantage will provide replacement gasket parts and pay repair facilities to install them at no cost to you.
Summarized — see the official notice for exact wording, dates, and contacts.
At a glance
What can fail
The striker component that latches second and third row seats may have improper welds, causing seats and seat belts to fail restraining passengers during a crash.
What the fix does
A dealer will install a reinforcement bracket on the striker of second and third row outboard seats.
Summarized — see the official notice for exact wording, dates, and contacts.
At a glance
What can fail
Welds on the outboard rear seat strikers for second and third row seats may fail during front or rear impact crashes. Second row seats may not withstand required crash loads.
What the fix does
Dealers will weld a reinforcement bracket onto the outboard seat strikers on second and third row seats at no charge.
Summarized — see the official notice for exact wording, dates, and contacts.
At a glance
What can fail
Rear brake caliper pistons lack sufficient coating, allowing gas pockets to form and reducing rear brake stopping power.
What the fix does
Dealers will bleed the brake system to remove gas pockets and restore brake performance at no cost.
Summarized — see the official notice for exact wording, dates, and contacts.
