152 of 25,867 recalls from Transport Canada and NHTSA.
NOTE: VEHICLES EQUIPPED WITH 2.5 LITRE ENGINES. THESE VEHICLES DO NOT COMPLY WITH C.M.V.S.S. 1103 - EXHAUST EMISSIONS. CATALYSTS AND OXYGEN SENSORS MAY BE DEFECTIVE.
No risk description available.
CATALYTIC CONVERTER AND OXYGEN SENSOR WILL BE REPLACED WITH REDESIGNED COMPONENTS.
NOTE: APPLIES TO VEHICLES WITH 5.2 LITRE ENGINE. THESE VEHICLES DO NOT COMPLY WITH C.M.V.S.S 1103 - EXHAUST EMISSIONS. VEHICLE EMISSION CONTROL INFORMATION LABEL SPECIFIES AN INCORRECT SPARK PLUG FOR THIS APPLICATION.
No risk description available.
CORRECT LABELS AND INSTALLATION INSTRUCTIONS WILL BE MAILED TO OWNERS.
Certain vehicles do not comply with CMVSS 1101 - Emission Device. Vehicles were built with incorrect vehicle emission control labels.
No risk description available.
New labels will be installed on affected vehicles.
NOTE: VEHICLES WITH 3.9 LITRE ENGINE AND AUTOMATIC TRANSMISSION. THESE VEHICLES DO NOT COMPLY WITH C.M.V.S.S. 1101 - EMISSION DEVICE. VEHICLES WERE BUILT WITH AN INCORRECT UNDERHOOD EMISSION INFORMATION (VECI) LABEL. THE LABELS INCORRECTLY IDENTIFY THE VEHICLE AS CERTIFIED TO CALIFORNIA STANDARDS.
No risk description available.
OWNERS WILL BE SUPPLIED WITH CORRECT LABELS AND INSTALLATION INSTRUCTIONS.
NOTE: THUNDERBIRD SUPER COUPE AND COUGAR XR7 EQUIPPED WITH MANUAL TRANSMISSION AND 3.8 LITRE SUPERCHARGED ENGINE. THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S. 1103 - EXHAUST EMISSIONS. HIGHER THAN ANTICIPATED EXHAUST SYSTEM TEMPERATURES MAY CAUSE DAMAGE TO THE EXHAUST SYSTEM CATALYST THEREBY INCREASING EXHAUST EMISSION LEVELS IN EXCESS OF THE STANDARD.
No risk description available.
DEALERS WILL REPLACE EXHAUST SYSTEM CATALYST ASSEMBLY AND POWERTRAIN CONTROL MODULE.
THE MAINTENANCE SCHEDULE SPECIFIES A 30,000 MILE (48,000 KM) INTERVAL BETWEEN SPARK PLUG CHANGES INSTEAD OF THE CORRECT 22,500 MILE (36,000KM) INTERVAL. THE INCORRECT INTERVAL IF FOLLOWED MAY AFFECT AIR EMISSION CONTROL PERFORMANCE. THESE VEHICLES DO NOT COMPLY WITH CANADA MOTOR VEHICLE SAFETY STANDARD 1103 - EXHAUST EMISSIONS.
No risk description available.
No remedy description available.
THESE VEHICLES DO NOT COMPLY WITH C.M.V.S.S. 1101-EMISSION DEVICE. INCORRECT INFORMATION ON EMISSION LABEL.
No risk description available.
No remedy description available.
Certain vehicles do not comply with the requirements of CMVSS 1101 - Emission Device. Vehicles were built with incorrect emission control labels. The emission control (tune up) labels have an incorrect emission vacuum hose routing schematic.
No risk description available.
Dealers will install a new vehicle emission control label on the radiator support.
THESE VEHICLES DO NOT COMPLY WITH C.M.V.S.S. 1101 - EMISSION DEVICE. MISSING EMISSION CONTROL LABEL.
No risk description available.
No remedy description available.
NOTE: VEHICLES WITH 2.4 LITRE ENGINE. THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S. 1105 - EVAPORATIVE EMISSIONS. VEHICLES MAY HAVE BEEN BUILT WITH AN INCORRECT EVAPORATIVE EMISSION (EVAP) CANISTER PURGE SOLENOID.
No risk description available.
EVAPORATIVE EMISSION (EVAP) CANISTER PURGE SOLENOID WILL BE REPLACED WITH THE CORRECT PART NUMBER COMPONENT.
THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S. 1103 - EXHAUST EMISSIONS. VEHICLES MAY HAVE FUEL TANK VAPOUR HOSE THAT IS TOO LONG AND MAY BE KINKED NEAR THE CONNECTION TO THE EVAPORATIVE EMISSIONS CANISTER.
No risk description available.
HOSES WILL BE INSPECTED AND LENGTH REDUCED IF NECESSARY.
THESE VEHICLES DO NOT COMPLY WITH C.M.V.S.S. 1103 - EXHAUST EMISSIONS. NITROUS OXIDE LEVELS EXCEED THE STANDARD.
No risk description available.
OWNERS WILL BE PROVIDED WITH REVISED STARTING INSTRUCTIONS FOR THE OWNER GUIDE. CERTAIN VEHICLES WILL HAVE THE ENGINE EMISSIONS CONTROL SYSTEMS MODIFIED AND EXHAUST SYSTEM CATALYSTS REPLACED.
CERTAIN VEHICLES DO NOT COMPLY WITH C.M.V.S.S. 1103 - EXHAUST EMISSIONS.
No risk description available.
No remedy description available.
Certain Spirit and Acclaim with a 2.5 litre flex-fuel engine and Intrepid with a 3.3 litre flex-fuel engine do not comply with the requirements of CMVSS 1101 - Emission Device. The methanol fuel sensor may fail due to grounding of the circuit board and a software problem.
No risk description available.
An improved methanol concentration sensor will be installed on affected vehicles.
NOTE: SUPERSEDED BY 95038. THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S 1103 - EXHAUST EMISSIONS. CATALYSTS MAY BE RELEASING EMISSIONS IN EXCESS OF THE STANDARD.
No risk description available.
EXHAUST SYSTEM CATALYSTS WILL BE REPLACED ON AFFECTED VEHICLES.
On certain Mustang GT vehicles equipped with 4.6 litre, 2-valve engines, the transmission control wire harness may chafe against the EGR tube and sleeve possibly damaging the harness convolute and wires. This damage could cause powertrain and emission control concerns such as illumination of the Malfunction Indicator Lamp (MIL), engine not starting and the transmission failing to upshift.
No risk description available.
Transmission harness will be inspected for damage and repaired or replaced and rerouted as necessary.
THESE VEHICLES DO NOT COMPLY WITH C.M.V.S.S. 1103 - EXHAUST EMISSIONS. SIGNAL WIRES FOR THE OXYGEN SENSORS ARE COULD BE INCORRECTLY POSITIONED IN THE ECM WIRING HARNESS CONNECTOR. THIS COULD RESULT IN EMISSIONS EXCEEDING THE STANDARD.
No risk description available.
WIRING HARNESS WILL BE MODIFIED BY ADDING AN ADAPTER HARNESS TO CORRECT THE SIGNAL WIRE ROUTING.
Certain 750IL vehicles fail to comply with the requirements of CMVSS 1103 - Exhaust Emissions
No risk description available.
No remedy description available.
NOTE: THIS RECALL IS A DUPLICATE OF 94-045.
No risk description available.
No remedy description available.
THESE VEHICLES DO NOT COMPLY WITH C.M.V.S.S. 1103 - EXHAUST EMISSIONS.
No risk description available.
No remedy description available.
We may earn a commission for purchases made through these links.
