Chrysler (FCA US, LLC) is recalling certain 2020-2021 Alfa Romeo Stelvio, and Alfa Romeo Giulia vehicles. The fuel line sensor housing may crack and leak fuel.
Safety Risk
A fuel leak may cause an engine stall, increasing the risk of a crash. A fuel leak also increases the risk of fire in the presence of an ignition source.
Remedy
Dealers will inspect and replace the fuel line sensor housing, as necessary, free of charge. Owner notification letters were mailed on January 11, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y91.
11,419 vehicles affectedMfr ref: Y91Updated June 10, 2026
Chrysler (FCA US, LLC) is recalling certain 2020-2021 Alfa Romeo Stelvio, and Alfa Romeo Giulia vehicles. The fuel line sensor housing may crack and leak fuel.
Safety Risk
A fuel leak may cause an engine stall, increasing the risk of a crash. A fuel leak also increases the risk of fire in the presence of an ignition source.
Remedy
Dealers will inspect and replace the fuel line sensor housing, as necessary, free of charge. Owner notification letters were mailed on January 11, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y91.
11,419 vehicles affectedMfr ref: Y91Updated June 10, 2026
ON VEHICLES WITH DUAL FUEL TANKS, THE DUAL FUNCTION FUEL RESERVOIR (DFR) MAY MALFUNCTION ALLOWING SUPPLY FUEL TO BE DRAWN FROM ONE TANK AND A PORTION OF THE UNUSED FUEL TO BE RETURNED TO THE OTHER TANK. AS A RESULT, THE OTHER TANK COULD POSSIBLY BE OVERFILLED, RESULTING IN OVERFLOW OF FUEL PAST THE FILLER CAP. IN THE PRESENCE OF AN IGNITION SOURCE, THE POTENTIAL FOR A FIRE MAY EXIST.
Safety Risk
No risk description available.
Remedy
A DFR CONTAINING "O" RINGS MANUFACTURED FROM REVISED MATERIAL WILL BE INSTALLED ON AFFECTED VEHICLES.
21,304 vehicles affectedMfr ref: 91S39Updated June 10, 2026
Nissan North America, Inc. (Nissan) is recalling certain 2022 Frontier Crew Cab Long Bed trucks. The tow hitch was not installed, compromising the structural integrity of the fuel tank in the event of a rear crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 301, "Fuel System Integrity."
Safety Risk
During a crash, the leaf spring could contact the fuel tank, causing a fuel leak and increasing the risk of a fire or injury.
Remedy
Dealers will install the tow hitch and harness kit, free of charge. Owner notification letters were mailed December 16, 2021. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PC855.
22 vehicles affectedMfr ref: PC855Updated June 10, 2026
On certain motorcycles, engine vibration can cause the fuel tank fitting bracket to contact the fuel tank. Over time, this contact may cause fatigue cracking and could result in possible fuel leakage, which in the presence of an ignition source, could result in a fire. In addition, it is possible for water to contaminate the main switch and develop corrosion, which may cause the engine to stall while riding. Both of these conditions could increase the risk of a crash causing injury and/or damage to property.
Safety Risk
No risk description available.
Remedy
Dealers will replace the fuel tank bracket and the main switch subassembly with parts of a different design.
2,760 vehicles affectedMfr ref: M17-058Updated June 10, 2026
On certain motorcycles, the threaded inserts that affix the internal overflow pipe to the fuel tank could leak due to an irregularity in the coating process. This could result in a fuel leak, which in the presence of an ignition source, could result in a fire causing injury and/or property damage.
Safety Risk
No risk description available.
Remedy
Dealers will inspect the threaded inserts for leaks, and repair if necessary.
THE HOT PLATE WELD WHICH ATTACHES THE VAPOUR VENT VALVE TO THE TOP OF THE PLASTIC FUEL TANK MAY PARTIALLY FRACTURE, ALLOWING VAPOUR OR FUEL TO ESCAPE FROM THE TOP OF THE TANK THROUGH THE FRACTURE. IN THE PRESENCE OF AN IGNITION SOURCE A FIRE COULD RESULT.
Safety Risk
No risk description available.
Remedy
TANKS WILL BE REMOVED AND INSPECTED FOR THE WELD INTEGRITY OF THE VAPOUR VENT VALVE CARRIER. TANKS WITH INADEQUATE WELDS WILL BE REPLACED.
1,234 vehicles affectedMfr ref: 91S30Updated June 10, 2026
THE FUEL TANK ON THESE VEHICLES COULD CORRODE AT THE BOTTOM OF THE TANK IN THE AREA ABOVE THE STONE GUARD. IF CORROSION WERE TO PERFORATE THE FUEL TANK WALL, FUEL WOULD SEEP INTO THE SPACE BETWEEN THE TANK AND STONE GUARD. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Safety Risk
No risk description available.
Remedy
FUEL TANK WILL BE REPLACED.
71 vehicles affectedMfr ref: D873Updated June 10, 2026
FORD MOTOR COMPANY IS RECALLING 429 MY 2009 FORD ECONOLINE E-350 AND E-450 CUTAWAY SCHOOL BUS PREP PACKAGE VEHICLES MANUFACTURED FROM APRIL 22, 2008 THROUGH MARCH 2, 2009, TO REPOSITION THE UPPER FUEL TANK PROTECTION BRACKET ON THE FRAME RAIL.
Safety Risk
IN CERTAIN TYPES OF VERY SEVERE CRASHES, THE FUEL TANK MAY BE DAMAGED AND RESULT IN A LEAK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy
FORD WILL NOTIFY OWNERS AND DEALERS WILL REPOSITION THE UPPER FUEL TANK PROTECTION BRACKET FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE APRIL 14, 2009. OWNERS MAY CONTACT FORD TOLL-FREE AT 1-866-436-7332 OR CONTACT A LOCAL FORD OR LINCOLN/MERCURY DEALER FOR MORE INFORMATION.
Piaggio Group Americas, Inc. (Piaggio) is recalling certain model year 2013 Vespa 946 scooters manufactured August 6, 2013, through October 15, 2013. The affected scooters have fuel line that may leak.
Safety Risk
A fuel line leak may result in the scooter stalling, increasing the risk of a crash. Additionally, a fuel leak in the presence of an ignition source may result in a fire.
Remedy
Piaggio has notified owners, and dealers will replace the fuel line, free of charge. The recall began on August 12, 2014. Owners may contact Piaggio customer service at 1-212-380-4433.
NOTE: VEHICLES LOCATED IN EASTERN BRITISH COLUMBIA, ALBERTA, YUKON, NORTHWEST TERRITORIES, SASKATCHEWAN, MANITOBA AND NORTHWESTERN ONTARIO.
UNDER CONDITIONS OF EXTREME COLD AND VERY LOW HUMIDITY, FUEL FLOW MAY CAUSE AN ELECTROSTATIC CHARGE TO BUILD UP TO A SUFFICIENT LEVEL TO DISCHARGE TO GROUND THROUGH THE NYLON FUEL LINE THAT CONNECTS THE FUEL PUMP TO THE FUEL FILTER. THIS COULD FORM A PIN HOLE IN THE FUEL LINE ALLOWING FUEL LEAKAGE TO OCCUR. IN THE PRESENCE OF AN IGNITION SOURCE, SUCH AS AN ELECTROSTATIC CHARGE FROM THE FUEL FILTER, A FIRE COULD RESULT.
Safety Risk
No risk description available.
Remedy
No remedy description available.
394 vehicles affectedMfr ref: 90S17Updated June 10, 2026
Ford Motor Company (Ford) is recalling certain 2012 and 2017 Focus vehicles equipped with 2.0L GDI gasoline engines and 2013-2014 Focus ST vehicles equipped with 2.0L GTDI engines, previously recalled under 18V-735. The affected vehicles did not have the Powertrain Control Module (PCM) updated as intended. Therefore, the Canister Purge Valve (CPV) may malfunction, possibly causing excessive vacuum in the fuel vapor management system.
Safety Risk
The excessive vacuum may result in an engine stall while driving, without warning and without the ability to restart the vehicle, increasing the risk of a crash.
Remedy
Ford will notify owners, and dealers will reprogram the Powertrain Control Module. Dealers will also check for fault codes and replace the CPV as needed. If the CPV is replaced, dealers will inspect and replace the carbon canister, fuel tank and fuel delivery module as necessary. The recall began July 29, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S22.
Over time, small cracks could develop in the fuel pump outlet. If this happens, there could be a fuel odour or fuel leak under the rear seat area.
Safety Risk
A fuel leak can create the risk of a fire.
Remedy
Porsche will notify owners by mail and instruct you to take your vehicle to a dealer to replace the fuel pump service cover. The fuel filter flanges will be inspected, and replaced if any cracks are found.
11,349 vehicles affectedMfr ref: ALA2Updated June 10, 2026
THE FUEL FEED OR FUEL RETURN HOSE AT THE ENGINE MAY RUB AGAINST A SHIFT LEVER ON THE 5-SPEED TRANSAXLE. WITH TIME, A HOLE COULD BE RUBBED THROUGH THE HOSE AND FUEL COULD LEAK INTO THE ENGINE COMPARTMENT CREATING THE POTENTIAL FOR AN UNDERHOOD FIRE.
Safety Risk
No risk description available.
Remedy
DEALERS WILL REPLACE THE FUEL FEED AND RETURN HOSE/PIPE ASSEMBLIES.
2,746 vehicles affectedMfr ref: 8A14/88065Updated June 10, 2026
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Safety Risk
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. THE CAMPAIGN BEGAN ON APRIL 16, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
On certain vehicles, a weld between the fuel tank inlet valve and the fuel tank was not made to specification and can fail. If these parts separate, the driver may notice an odour of fuel, the Service Engine Soon or Check Engine light may illuminate, and/or fuel may leak onto the ground. If a sufficient amount of fuel leaked and if an ignition source were present, a vehicle fire could occur.
Safety Risk
No risk description available.
Remedy
Dealer will inspect the fuel tank and replace it if necessary.
9 vehicles affectedMfr ref: 03055Updated June 10, 2026
KTM North America, Inc. is recalling certain 2024 390 Duke, 250 Duke, 990 Duke, Husqvarna Vitpilen 401, and Husqvarna Svartpilen 401 motorcycles. The seal on the fuel filler cap may develop cracks and leak fuel.
Safety Risk
A fuel leak increases the risk of fire or injury.
Remedy
Dealers will inspect and replace the fuel cap gasket, free of charge. Owner notification letters were mailed December 15, 2025. Owners may contact KTM customer service at 1-888-985-6090. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov March 31, 2026.
KTM North America, Inc. is recalling certain 2024 390 Duke, 250 Duke, 990 Duke, Husqvarna Vitpilen 401, and Husqvarna Svartpilen 401 motorcycles. The seal on the fuel filler cap may develop cracks and leak fuel.
Safety Risk
A fuel leak increases the risk of fire or injury.
Remedy
Dealers will inspect and replace the fuel cap gasket, free of charge. Owner notification letters were mailed December 15, 2025. Owners may contact KTM customer service at 1-888-985-6090. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov March 31, 2026.
KTM North America, Inc. is recalling certain 2024 390 Duke, 250 Duke, 990 Duke, Husqvarna Vitpilen 401, and Husqvarna Svartpilen 401 motorcycles. The seal on the fuel filler cap may develop cracks and leak fuel.
Safety Risk
A fuel leak increases the risk of fire or injury.
Remedy
Dealers will inspect and replace the fuel cap gasket, free of charge. Owner notification letters were mailed December 15, 2025. Owners may contact KTM customer service at 1-888-985-6090. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov March 31, 2026.
KTM North America, Inc. is recalling certain 2024 390 Duke, 250 Duke, 990 Duke, Husqvarna Vitpilen 401, and Husqvarna Svartpilen 401 motorcycles. The seal on the fuel filler cap may develop cracks and leak fuel.
Safety Risk
A fuel leak increases the risk of fire or injury.
Remedy
Dealers will inspect and replace the fuel cap gasket, free of charge. Owner notification letters were mailed December 15, 2025. Owners may contact KTM customer service at 1-888-985-6090. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov March 31, 2026.
