Ford Motor Company (Ford) is recalling certain 2020 Lincoln Aviator and Ford Explorer vehicles. The rear lower control arm (RLCA) bolts that attach the rear lower control arms to the wheel knuckles may not have been heat-treated, which could cause them to break.
Safety Risk
Broken RLCA bolts can cause a loss of steering control, and increase the risk of a crash.
Remedy
Ford will notify owners, and dealers will replace both RLCA bolts, free of charge. The recall began on April 2, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S11.
49 vehicles affectedMfr ref: 21S11Updated June 10, 2026
On certain vehicles, an underbody heat shield may not be long enough to protect the right drive half-shaft grease boot from heat. Over time, this could lead to a grease leak from the boot. If leaking grease comes into contact with heated surfaces of the exhaust system and/or diesel particulate filter (DPF), it could lead to a fire potentially causing injury and/or damage to property.
Safety Risk
No risk description available.
Remedy
Dealers will install a revised heat shield and certain vehicles will have the upper boost hose replaced.
10,106 vehicles affectedMfr ref: 23W5Updated June 10, 2026
On certain XC40 Recharge models, water may enter the wire harness for the accelerator pedal. If this happens, the accelerator pedal may not work properly. This problem could also cause the vehicle not to start.
Safety Risk
An accelerator pedal that does not work properly could cause a loss of power to the wheels or a sudden unintended acceleration. Both could increase the risk of a crash.
Remedy
Volvo will notify owners by mail and instruct you to take your vehicle to a dealership to add a cable splice to the accelerator pedal wiring.
459 vehicles affectedMfr ref: R10170Updated June 10, 2026
On certain vehicle equipped with 16 inch tires and operated in hot ambient conditions, the rubber and metal portions of the valve stem may experience separation or cracking. This condition may lead to loss of air pressure at the valve stem and subsequent rapid loss of pressure in the tire that could result in a loss of vehicle directional control with minimal advance warning.
Safety Risk
No risk description available.
Remedy
Dealers will replace the tire valve stems.
1,397 vehicles affectedMfr ref: D53Updated June 10, 2026
THE REAR SPRING PLATES (RADIUS ARMS) ON THESE VEHICLES MAY HAVE BEEN IMPROPERLY TEMPERED BY SUPPLIER. IMPROPERLY HARDENED SPRING PLATES COULD CRACK AND POSSIBLY BREAK . THIS COULD AFFECT LATERAL GUIDANCE OF THE CORRESPONDING REAR WHEEL RESULTING IN LOSS OF VEHICLE CONTROL.
Safety Risk
No risk description available.
Remedy
No remedy description available.
109 vehicles affectedMfr ref: JUUpdated June 10, 2026
Tesla, Inc. (Tesla) is recalling certain 2025 Model 3 and 2026 Model Y vehicles. The battery pack contactors may fail, causing a loss of drive power.
Safety Risk
A loss of drive power can increase the risk of a crash.
Remedy
Tesla Service will replace the battery pack contactors, free of charge. Owner notification letters were mailed December 9, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-16-005.
12,963 vehicles affectedMfr ref: SB-25-16-005Updated June 10, 2026
Tesla, Inc. (Tesla) is recalling certain 2025 Model 3 and 2026 Model Y vehicles. The battery pack contactors may fail, causing a loss of drive power.
Safety Risk
A loss of drive power can increase the risk of a crash.
Remedy
Tesla Service will replace the battery pack contactors, free of charge. Owner notification letters were mailed December 9, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-16-005.
12,963 vehicles affectedMfr ref: SB-25-16-005Updated June 10, 2026
Ford Motor Company (Ford) is recalling certain model year 2016 Ford F-650 and F-750 trucks manufactured April 15, 2015, to December 15, 2015, and equipped with rear air suspension. In the affected vehicles, the rear brake hoses may contact and chafe on the rear axle housing while driving.
Safety Risk
A chafed rear brake line may result in an air leak, reducing the rear braking ability and increasing the risk of a crash.
Remedy
Ford will notify owners, and dealers will install revised rear brake air chambers and replace any damaged rear air brake lines, free of charge. The recall began on February 9, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S38.
302 vehicles affectedMfr ref: 15S38Updated June 10, 2026
Ford Motor Company (Ford) is recalling certain model year 2016 Ford F-650 and F-750 trucks manufactured April 15, 2015, to December 15, 2015, and equipped with rear air suspension. In the affected vehicles, the rear brake hoses may contact and chafe on the rear axle housing while driving.
Safety Risk
A chafed rear brake line may result in an air leak, reducing the rear braking ability and increasing the risk of a crash.
Remedy
Ford will notify owners, and dealers will install revised rear brake air chambers and replace any damaged rear air brake lines, free of charge. The recall began on February 9, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S38.
302 vehicles affectedMfr ref: 15S38Updated June 10, 2026
On certain vehicles, the evaporative emission control systems may apply excessive vacuum to the fuel tanks during the canister purge cycle. Minor fuel tank distortion could result. A small crack could develop on the upper fuel tank surface. The "Check Engine" light would then illuminate and, in some cases, the vehicle driver could notice a gasoline odor. Fuel leakage in the presence of an ignition source can result in a fire.
Safety Risk
No risk description available.
Remedy
Dealers will pressure check the vehicle's fuel tank to determine if it has cracked. If it is cracked, a new fuel tank will be installed. A new fuel filler cap that decreases the amount of vacuum inside the fuel tank will also be installed.
11,571 vehicles affectedMfr ref: R-28Updated June 10, 2026
On certain vehicles, a fuel injector may crack. If this happens, fuel could leak into the engine compartment.
Note: This recall only affects vehicles equipped with a 1.5 L EcoBoost engine. This recall replaces Transport Canada recalls 2022-658, 2024-160 and 2025-134.
Safety Risk
A fuel leak can create the risk of a fire.
Remedy
Ford will notify owners by mail. As an interim repair, a dealer will update the engine control software to detect fuel injector leaks. Owners that have already received this software update will be informed that the interim repair is not required. Once the final repair is available, Ford will notify owners by mail and advise you to take your vehicle to a dealership to replace the high-pressure fuel rail assembly, high-pressure fuel injectors, and update the engine control software.
70,618 vehicles affectedMfr ref: 25S76Updated June 10, 2026
A CONDITION MAY EXIST WHEREBY THE WIRING HARNESS MAY CHAFE AGAINST THE WINDSHIELD WIPER MOTOR BRACKET. THIS COULD RESULT IN A SHORT CIRCUIT AND A POSSIBLE VEHICLE FIRE.
Safety Risk
No risk description available.
Remedy
RUBBER PROTECTIVE STRIPS WILL BE INSTALLED ON THE EDGES OF THE WINDSHIELD WIPER MOTOR BRACKET TO PREVENT THIS CONDITION.
On certain vehicles equipped with a 2.0 L turbo engine, the high-pressure fuel pump could fail. If this happens, the engine could suddenly lose power and stall while driving.
Safety Risk
A sudden loss of engine power could increase the risk of a crash.
Remedy
Kia will notify owners by mail and advise you to take your vehicle to a dealership to inspect the high-pressure fuel pump, and replace it if necessary. The dealer will also update the engine control unit software to prevent a loss of engine power while driving.
241 vehicles affectedMfr ref: RC188Updated June 10, 2026
THE FUEL SUPPLY TUBE FROM THE FUEL PUMP TO THE FUEL FILTER COULD EXPERIENCE FATIGUE CRACKING AT THE FUEL PUMP END AS THE RESULT OF RESONANT VIBRATION DURING VEHICLE OPERATION. THIS COULD RESULT IN FUEL LEAKAGE AND PRESENT THE POTENTIAL FOR FIRE.
Safety Risk
No risk description available.
Remedy
No remedy description available.
8,066 vehicles affectedMfr ref: 225TUpdated June 10, 2026
THE UPPER STEERING COLUMN LOCKNUT WAS MANUFACTURED WITH A LOWER CLASS OF MATERIAL WHICH COULD RESULT IN A LOSS OF TIGHTENING TORQUE ON THE UPPER STEERING COLUMN FASTENER. LOOSENING OF THE FASTENER COULD RESULT IN PLAY IN THE STEERING SYSTEM AND CONSEQUENTIAL IMPAIRMENT OF HANDLING.
Safety Risk
No risk description available.
Remedy
LOCKNUT WILL BE REPLACED WITH ONE HAVING IMPROVED SELF-LOCKING PROPERTIES.
23 vehicles affectedMfr ref: 148Updated June 10, 2026
Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2013-2015 Outlander Sport vehicles originally sold, or ever registered, in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin. The front lower control arms may detach due to the front cross member corroding from salt water exposure, such as from road salt use.
Safety Risk
A detached front control arm can result in a loss of vehicle control, increasing the risk of a crash.
Remedy
MMNA will notify owners, and dealers will inspect the front cross members. Depending on the level of existing corrosion, either a sealing/anti-corrosion agent will be applied, or the front cross member will be replaced with a new one, free of charge. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-21-001. This recall is an expansion of NHTSA recall number 20V-279. Owners not previously notified under 20V-279 were notified on March 22, 2021.
Kia America, Inc. (Kia) is recalling certain 2022 Sorento Plug-In Hybrid (PHEV) vehicles. The fuel tank may have been improperly molded, which can result in a fuel leak.
Safety Risk
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy
Deales will inspect and replace the fuel tank, as necessary, free of charge. Owner notification letters were mailed March 22, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC261.
34 vehicles affectedMfr ref: SC261Updated June 10, 2026
ON VEHICLES WITH OPTIONAL FRONT SEAT RECLINERS, THE UPPER SHOULDER SCREW THAT ATTACHES THE DRIVER'S SEAT BACK FRAME TO THE RECLINER MECHANISM MAY BE SUSCEPTIBLE TO FATIGUE FRACTURE. IF FATIGUE FRACTURE OF THE RECLINER UPPER ATTACHMENT SCREW WERE TO OCCUR ON THE DRIVER'S SEAT, THE SEAT BACK COULD ROTATE REARWARD TO A NEAR HORIZONTAL POSITION WITHOUT WARNING POTENTIALLY AFFECTING THE DRIVER'S CONTROL OF THE VEHICLE.
Safety Risk
No risk description available.
Remedy
No remedy description available.
3,721 vehicles affectedMfr ref: 492Updated June 10, 2026
