VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ELECTRICAL WIRING LOCATED IN THE ENGINE COMPARTMENT WAS ROUTED TOO CLOSE TO THE ENDGE OF THE VEHICLE'S BATTERY TRAY. THE WIRING CAN BECOME DAMAGED OVER TIME BY CHAFING AND THE AIR-CONDITIONER COMPRESSOR AND/OR THE FUEL PUMP CAN MALFUNCTION.
Safety Risk
A MALFUNCTION OF THE FUEL PUMP CAN CAUSE THE VEHICLE TO STALL, AND IN SOME INSTANCES, COULD ALSO RESULT IN A WIRING FIRE IN THE ENGINE COMPARTMENT.
Remedy
DEALERS WILL INSTALL A MODIFIED BATTERY TRAY AND INSPECT, PROPERLY ROUTE, AND SECURING THE WIRING IN ACCORDANCE WITH THE RECALL REPAIR INSTRUCTIONS.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. A GROUND CONNECTION TERMINAL WAS NOT PROPERLY CRIMPED IN THE SUPPLIER'S ENGINE WIRING HARNESS MANUFACTURING LINE. THIS IMPROPER CRIMPING PROCESS CAN LEAVE AN IMPRESSION ON THE TERMINAL THAT WILL EVENTUALLY CAUSE A STRESS FRACTURE.
S
Safety Risk
IF A TERMINAL IS FRACTURED, THE POWERTRAIN CONTROL MODULE (PCM) CAN RECEIVE AN ERRONEOUS SIGNAL INDICATING A HIGH VEHICLE SPEED, THEREBY CAUSING THE PCM TO CUT THE FUEL, CAUSING A 'NO-START' CONDITION, OR A POSSIBLE ENGINE STALL.
Remedy
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE VEHICLES.
Kia Motors America (Kia) is recalling certain 2018 Kia Stinger vehicles. The front wiring harness located in the engine and passenger compartment may get damaged from contacting a burr on the left fender body panel.
Safety Risk
The damaged wiring harness may short circuit, increasing the risk of a fire.
Remedy
Kia will notify owners, and dealers will inspect the wiring harness for damage. If no damage is found, a cover will be installed. If damage is found, the wiring harness will be replaced and a cover will be installed, free of charge. The recall began December 20, 2018. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall SC170.
16,011 vehicles affectedMfr ref: SC170Updated June 10, 2026
THE PROTECTIVE COVER FOR THE UNDERHOOD FUSE CENTER WAS OMITTED. WITHOUT THIS COVER, THE POSITIVE TERMINAL BOLT ON THE FUSE BLOCK IS EXPOSED AND CAN CONTACT THE INSULATED NEGATIVE BATTERY CABLE. IF THE INSULATION ON THE NEGATIVE CABLE BECOMES SUFFICIENTLY WORN, AN ELECTRICAL SHORT CIRCUIT CAN OCCUR BETWEEN THE POSITIVE TERMINAL AND NEGATIVE CABLE RESULTING IN EXTREMELY HIGH CURRENT FLOW.
Safety Risk
THIS HIGH CURRENT FLOW CAN CAUSE ARCING AND RESULT IN AN UNDERHOOD FIRE.
Remedy
DEALERS WILL INSPECT THESE VEHICLES FOR THE PRESENCE OF THE PROTECTIVE COVER AND, IF NECESSARY, INSTALL A PROTECTIVE COVER TO THE UNDERHOOD FUSE CENTER.
VEHICLE DESCRIPTION: MINI VANS. HEAT GENERATION IN THE WIRING HARNESS TO THE FUEL PUMP/SENDER ASSEMBLY CAN CAUSE AN ELECTRICAL SHORT. THE VEHICLE COULD EXPERIENCE A LOSS OF POWER AND BECOME IMMOBILIZED AND THE FUEL GAUGE MAY BE ERRATIC.
Safety Risk
HEAT DAMAGE, INCLUDING MELTING OR CHARRING OF THE FUEL PUMP AND SENDER ASSEMBLY WIRE HARNESS AND ASSOCIATED WIRING HARNESSES CAN ALSO RESULT. THE SHORT CIRCUIT COULD ALSO HAVE THE POTENTIAL FOR A VEHICLE FIRE.
Remedy
DEALERS WILL INSTALL A FUSED JUMPER HARNESS IN THE FUEL PUMP GROUND CIRCUIT THAT WILL BE INSTALLED AT THE FUEL PUMP INERTIA SHUT-OFF SWITCH.
ON CERTAIN PASSENGER VEHICLES, THE MAIN UNDER HOOD ELECTRICAL WIRING HARNESS MAY HAVE INSUFFICIENT CLEARANCE BETWEEN THE ENGINE CONTROL HARNESS AND THE EXHAUST HEAT SHIELD. AS A RESULT, THE HARNESS COULD COME IN CONTACT WITH THE HEAT SHIELD, WHICH COULD RESULT IN MELTING OF THE HARNESS INSULATION.
Safety Risk
THE MELTING OF THE HARNESS INSULATION COULD RESULT IN GROUNDING OF THE CRANK ANGLE SENSOR WIRING, CAUSING THE ENGINE TO RUN ERRATICALLY OR STOP SUDDENLY, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL INSPECT THE HARNESS FOR DAMAGE AND, IF NONE IS EVIDENT, WILL TIE THE HARNESS BACK TO PREVENT THE HARNESS FROM EVER COMING INTO CONTACT WITH THE HEAT SHIELD. ANY HARNESS THAT SHOWS EVIDENCE OF DAMAGE WILL BE REPAIRED AS NECESSARY AND THEN TIED BACK TO PREVENT FUTURE DAMAGE. OWNER NOTIFICATION BEGAN MAY 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AT 1-800-222-0037.
THE WIRING HARNESS INSULATION CAN ABRADE ON A BRACE THAT RUNS FROM THE INSTRUMENT PANEL TO THE COWL.
Safety Risk
THIS CONDITION CAN RESULT IN AN ELECTRICAL SHORT AND POSSIBLY A VEHICLE FIRE.
Remedy
DEALERS WILL INSTALL A SHIELD ON THE INSTRUMENT PANEL TO COWL BRACE, AND INSTALLATION OF A PIECE OF CONVOLUTE WRAP MATERIAL ON ONE OF THE ADJACENT HARNESSES.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE VEHICLES. AN ENGINE ELECTRICAL WIRING-HARNESS CLIP CAN MELT AND DRIP ONTO THE EXHAUST MANIFOLD.
Safety Risk
THE CLIP MATERIAL ON THE EXHAUST MANIFOLD CAN IGNITE AND SUBSEQUENTLY IGNITE OTHER COMBUSTIBLE COMPONENTS RESULTING IN A VEHICLE FIRE.
Remedy
DEALERS ARE CONTACTING OWNERS BY TELEPHONE TO HAVE THEIR VEHICLES TOWED TO THE DEALER AND ALTERNATE TRANSPORTATION PROVIDED TO THEM UNTIL THE DEALER CAN REROUTE THE ELECTRICAL WIRING-HARNESS.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. A GROUND CONNECTION TERMINAL WAS NOT PROPERLY CRIMPED IN THE SUPPLIER'S ENGINE WIRING HARNESS MANUFACTURING LINE. THIS IMPROPER CRIMPING PROCESS CAN LEAVE AN IMPRESSION ON THE TERMINAL THAT WILL EVENTUALLY CAUSE A STRESS FRACTURE.
S
Safety Risk
IF A TERMINAL IS FRACTURED, THE POWERTRAIN CONTROL MODULE (PCM) CAN RECEIVE AN ERRONEOUS SIGNAL INDICATING A HIGH VEHICLE SPEED, THEREBY CAUSING THE PCM TO CUT THE FUEL, CAUSING A 'NO-START' CONDITION, OR A POSSIBLE ENGINE STALL.
Remedy
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE VEHICLES.
Nissan North America, Inc. (Nissan) is recalling certain 2016 Frontier V6 vehicles manufactured February 29, 2016, to March 7, 2016. The starter motor wire harness may have been installed in an incorrect position, allowing the starter harness terminal to contact the heat shield and result in an electrical short.
Safety Risk
An electrical short increases the risk of a fire.
Remedy
Nissan will notify owners, and dealers will inspect and reposition the starter wire harness, as necessary, free of charge. The recall began on April 13, 2016. Owners may contact Nissan customer service at 1-800-647-7261.
AN ENGINE COMPARTMENT ELECTRICAL WIRING HARNESS MAY HAVE BEEN ROUTED TOO CLOSE TO A SHEET METAL EDGE. THE WIRING CAN BECOME DAMAGED DURING NORMAL VEHICLE OPERATION DUE TO CHAFING, RESULTING IN AN ELECTRICAL SHORT.
Safety Risk
IF A SHORT OCCURS, EITHER THE ENGINE COULD STALL ORTHE RADIATOR FAN COULD STOP OPERATING CAUSING THE ENGINE TO OVERHEAT. EITHERCONDITION COULD RESULT IN A VEHICLE ACCIDENT.
Remedy
REROUTE AND SECURE VARIOUS WIRING HARNESSES INSIDE THE ENGINE COMPARTMENT.
Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.
Safety Risk
A vehicle stall can increase the risk of a crash.
Remedy
Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.
12,779 vehicles affectedMfr ref: U87Updated June 10, 2026
Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.
Safety Risk
A vehicle stall can increase the risk of a crash.
Remedy
Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.
12,779 vehicles affectedMfr ref: U87Updated June 10, 2026
Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.
Safety Risk
A vehicle stall can increase the risk of a crash.
Remedy
Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.
12,779 vehicles affectedMfr ref: U87Updated June 10, 2026
Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.
Safety Risk
A vehicle stall can increase the risk of a crash.
Remedy
Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.
12,779 vehicles affectedMfr ref: U87Updated June 10, 2026
Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.
Safety Risk
A vehicle stall can increase the risk of a crash.
Remedy
Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.
12,779 vehicles affectedMfr ref: U87Updated June 10, 2026
Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.
Safety Risk
A vehicle stall can increase the risk of a crash.
Remedy
Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.
12,779 vehicles affectedMfr ref: U87Updated June 10, 2026
Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.
Safety Risk
A vehicle stall can increase the risk of a crash.
Remedy
Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.
12,779 vehicles affectedMfr ref: U87Updated June 10, 2026
Also recalled in Canada