Triumph Motorcycles America, Ltd. (Triumph) is recalling certain 2022-2024 Speed Triple RS, and Speed Triple RR motorcycles. The engine may overheat and cause the fan motor to fail, resulting in a coolant leak.
Safety Risk
A coolant leak can increase the risk of injury.
Remedy
Dealers will replace the original engine software calibration with a new version, free of charge. Owner notification letters were mailed March 26, 2024. Owners may contact Triumph customer service at 1-678-854-2010. Triumph's number for this recall is SRAN 620.
Jaguar Land Rover North America, LLC (Land Rover) is recalling certain 2019-2021 Land Rover Range Rover PHEV and 2019-2022 Land Rover Range Rover Sport PHEV vehicles. The water pump pulley drive belt may become damaged or detach, which can allow the engine to overheat. An overheated engine can rupture the engine coolant elbow pipe, leaking coolant onto the turbocharger heat shield.
Safety Risk
Coolant leaking onto the turbocharger heat shield inside the engine compartment can increase the risk of a fire.
Remedy
Dealers will replace the engine coolant elbow and the turbocharger feed coolant pipe, free of charge. Owner notification letters were mailed May 19, 2023. Owners may contact Land Rover customer service at 1-800-637-6837. Land Rover's number for this recall is N785.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2017 Audi A5 Cabriolet, A5 Sedan and Audi Q5 vehicles, 2012-2015 Audi A6 vehicles and 2013-2016 Audi A4 Sedan and A4 allroad vehicles. These vehicles, equipped with 2.0l Turbo FSI engines, have an electric coolant pump that can either become blocked with debris from the cooling system causing it to overheat or can short-circuit from moisture within the pump.
Safety Risk
A blocked pump or a short-circuited pump can increase the risk of a fire.
Remedy
Audi will notify owners, and dealers will replace the pumps, free of charge. The recall began September 14, 2018. Owners may contact Audi customer service at 1-800-253-2834. Audi's number's for this recall is 19N3/19N4. Note: This recall is in additional to the coolant pump software update applied as a remedy under recall 17V002.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2017 Audi A5, A5 Cabriolet and Q5 vehicles, 2013-2016 Audi Allroad and Audi A4 vehicles and 2012-2015 Audi A6 vehicles. These vehicles, equipped with 2.0l Turbo FSI engines, have an electric coolant pump that can be blocked with debris from the cooling system, resulting in the pump overheating.
Safety Risk
If the coolant pump overheats, it can increase the risk of a fire.
Remedy
Audi will notify owners, and dealers will update the software so that the power supply to the coolant pump is deactivated if the pump becomes blocked with debris, free of charge. The recall is expected to begin February 20, 2017. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 19M1.
ON CERTAIN SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 4-CYLINDER ENGINES, THE WATER PUMP PULLEY CENTER HOLE WAS IMPROPERLY MACHINED.
Safety Risk
IN SOME INSTANCES, THE INTERFERENCE FIT BETWEEN THE INNER WALL OF THE PULLEY CENTER HOLE AND THE WATER PUMP DRIVE SHAFT WAS NOT AS TIGHT AS SPECIFIED IN THE DRAWING SPECIFICATION. THIS COULD RESULT IN THE WATER PUMP PULLEY DISLODGING FROM THE WATER PUMP SHAFT, WHICH CAN CAUSE SEVERE ENGINE DAMAGE/SEIZURE DURING VEHICLE USAGE.
Remedy
DEALERS WILL REPLACE THE WATER PUMP. OWNER NOTIFICATION BEGAN SEPTEMBER 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH 2.5L OHC ENGINES. ENGINE COOLANT CIRCULATION THROUGH THE HEATER CIRCUIT IS PREVENTED BECAUSE OF A PLUGGED HEATER RETURN TUBE (WATER PUMP INLET TUBE) AT THE WATER PUMP. THESE VEHICLES DO NOT COMPLY WITH THE INTENT OF FMVSS NO. 103, "WINDSHIELD DEFROSTING AND DEFOGGING SYSTEMS."
Safety Risk
AS A RESULT OF NO HEAT IN THE HEATER CIRCUIT, DEFROST PERFORMANCE IS COMPROMISED.
Remedy
DEALERS WILL REPLACE THE PLUGGED HEATER WATER RETURN TUBES.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH VR6 ENGINES. A COOLANT SYSTEM COMPONENT SUCH AS THE THERMO SWITCH, RADIATOR FAN, OR WATER PUMP, CAN MALFUNCTION CAUSING THE COOLANT TEMPERATURE AND COOLANT SYSTEM PRESSURE TO INCREASE SIGNIFICANTLY. OVER TIME, EXCESSIVE PRESSURE CAN CAUSE LEAKAGE OF COOLANT FROMTHE SYSTEM, INCLUDING LEAKAGE FROM THE HEAT EXCHANGER.
Safety Risk
LEAKAGE OF HOT COOLANT FROM THE HEAT EXCHANGER CAN CAUSE INJURY TO THE FEET OF THE DRIVER OR STEAM UP THE INTERIOR OF THE VEHICLE TEMPORARILY IMPAIRING THE DRIVER'S VISION.
Remedy
DEALERS WILL INSTALL IN THE COOLANT INLET HOSE TO THE HEATER CORE, A PRESSURE REDUCER WITH A 5MM DIAMETER SECURED BY A SPRING TENSIONED HOSE CLAMP. ALSO A NEW RELAY THAT WILL CHANGE THE OPERATION OF THE SECONDARY ELECTRICAL COOLANT PUMP WILL BE INSTALLED. DEALERS WILL ALSO PERFORM A FUNCTIONAL CHECK OF THE COOLING SYSTEM TO MAKE SURE THAT ALL COOLING SYSTEM COMPONENTS OPERATE PROPERLY.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
Safety Risk
IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
Remedy
DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE ENGINE BACKFIRES DURING A COLD-START, AN AIR SCREEN WHICH IS LOOSELY SEATED IN THE AIR FLOW METER CAN BECOME DAMAGED.
Safety Risk
SCREEN PIECES COULD ENTER THE INTAKE AIR FLOW SYSTEM AND PREVENT THE THROTTLE PLATE FROM RETURNING TO ITS FULL IDLE POSITION.
Remedy
DEALERS WILL INSTALL A RETAINING RING TO HOLD THE AIR SCREEN IN PLACE.
IN THE EVENT THE ENGINE OVERHEATS AND THE VEHICLE IS OPERATED CONTINUOUSLY IN THAT CONDITION, THE COOLANT PRESSURE WILL RISE TO A LEVEL AT WHICH THE HEAT EXCHANGER COULD LEAK.
Safety Risk
A LEAKING HEAT EXCHANGER WILL ALLOW HOT COOLANT TO ESCAPE CAUSING INJURY TO THE DRIVER'S FEET OR COULD STEAM UP THE INTERIOR OF THE VEHICLE TEMPORARILY IMPAIRING THE DRIVER'S VISIBILITY, INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy
DEALERS WILL REPLACE THE HEAT EXCHANGER ON THESE VEHICLES.
THE INSIDE PIPES OF THE HEAT EXCHANGERS MIGHT BE SUBJECT TO CRACKING.
Safety Risk
WITH THE HEATER SWITCHED ON, EXHAUST FUMES FROM THE HEAT EXCHANGER COULD ENTER THE PASSENGER COMPARTMENT. ENTRY OF EXHAUST FUMES INTO THE PASSENGER COMPARTMENT COULD, IN EXTREME CASES, CAUSE ASPHYXIATION AND/OR LOSS OF VEHICLE CONTROL.
Remedy
DEALERS WILL REPLACE THE HEAT EXCHANGER IN THESE VEHICLES.
IN THE EVENT OF A COOLING SYSTEM COMPONENT FAILURE WHILE THE VEHICLE IS DRIVEN, THE COOLANT CAN OVERHEAT CAUSING THE COOLING SYSTEM PRESSURE TO RISE TO A LEVEL WHERE A LEAK IN THE HEAT EXCHANGER CAN OCCUR.
Safety Risk
A LEAK OR FAILURE OF THE HEAT EXCHANGER LOCATED UNDER THE DASHBOARD CAN ALLOW HOT COOLANT TO ESCAPE AND CAUSE INJURY TO THE FEET OF A PASSENGER. HOT COOLANT CAN ALSO STEAM UP THE INTERIOR OF THE VEHICLE TEMPORARILY IMPAIRING THE DRIVER'S VISIBILITY, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy
DEALERS WILL INSTALL A BYPASS VALVE KIT WHICH IS DESIGNED TO ROUTE EXCESSIVELY HOT COOLANT TO THE ENGINE WITHOUT FLOWING THROUGH THE HEAT EXCHANGER. DEALERS WILL ALSO INSTALL A PLASTIC COVER UNDERNEATH THE DASHBOARD ON THE PASSENGER SIDE TO ENSURE THAT THE PASSENGER IS NOT EXPOSED TO HOT COOLANT IN THE EVENT OF A LEAK.
THE RADIATOR CAP PRESSURE RELIEF VALVE RELEASE PRESSURE IS SET TOO HIGH. THIS CAN CAUSE THE COOLANT TO REACH TEMPERATURES THAT EXCEED THE THERMAL DESIGN LIMITS OF SOME COMPONENTS OF THE COOLANT SYSTEM. SHOULD THIS OCCUR, ENGINE COOLANT CAN LEAK COLLECT ON TOP OF THE ENGINE.
Safety Risk
IF ENGINE COOLANT LEAKS ONTO THE HOT ENGINE EXHAUST MANIFOLD FROM THE TOP OF THE ENGINE, AN ENGINE COMPARTMENT FIRE CAN RESULT.
Remedy
DEALERS WILL INSPECT THE VEHICLES AND IF ANY VEHICLE EXHIBITS COOLANT LEAKAGE OR IF THE COOLANT LEVEL HAS DROPPED TO THE POINT WHERE THE COOLANT LOSS WOULD BE SUFFICIENT TO TRIGGER THE COOLANT LEVEL WARNING SYSTEM, COMPONENTS POTENTIALLY SUBJECT TO DETERIORATION FROM OVERHEATING WOULD BE REPLACED. THESE PARTS INCLUDE THE WATER PUMP BEARING HOUSING, THE WATER LEVEL SENSOR AND RADIATOR UPPER HOSE, THE THERMOSTAT GASKET, AND ALL WATER HOSES LOCATED ABOVE THE ENGINE. IN ADDITION, ALL VEHICLES IN WHICH THOSE COMPONENTS ARE REPLACED WOULD ALSO HAVE THE COOLING SYSTEM AND OTHER SYSTEMS THAT CARRY FLAMMABLE LIQUIDS CHECKED TO MAKE CERTAIN THAT ENGINE OVERHEATING HAD NOT CAUSED ANY PROBLEMS IN THOSE SYSTEMS. ANY IDENTIFIED PROBLEMS WILL BE REPAIRED. THE RADIATOR CAP, FILLER CAP, AND FILLER CAP BODY OF ALL RECALLED VEHICLES WILL BE REPLACED BY NEWLY DESIGNED PARTS.
Also recalled in Canada