On ceratin trucks and bus chassis equipped with 7000 and 9000 pound front axles and air brakes. The front axle-to-spring u-bolts may fracture and separate due to improper heat treatment. If two u-bolts on the same side of the front axle should separate, the front axle could displace and result in a loss of steering control with little or no warning to the driver.
On certain vehicles, the low brake fluid warning lamp may not turn on if the brake fluid level gets too low. A low brake fluid level can cause reduced braking.
Safety Risk
A driver that isn't aware of a low brake fluid level could experience reduced braking and an increased risk of a crash.
Remedy
Tesla has released an over-the-air software update to fix this problem. There is no further action required if your vehicle has software release 2023.32.7 or a later release. Tesla will notify affected owners by email.
3,233 vehicles affectedMfr ref: SB-23-00-005Updated June 10, 2026
On certain vehicles, an electrical junction block could corrode due to exposure to road salt. This could result in an electrical short, potentially causing a loss of electrical power, smoke being emitted from the right front wheel well area, and increasing the risk of a fire causing injury and/or damage to property.
Safety Risk
No risk description available.
Remedy
Dealers will replace the junction block with an updated design.
6 vehicles affectedMfr ref: 14S11Updated June 10, 2026
NOTE: VEHICLES EQUIPPED WITH A 3.4 LITRE ENGINE.
WATER MAY BE DRAWN INTO THE EVAPORATIVE EMISSION CANISTER WHEN THE VEHICLE IS DRIVEN IN SLUSHY SNOW CONDITIONS. THE WATER IS THEN DELIVERED TO THE ENGINE WHICH CAN RESULT IN SETTING AN MIL (MALFUNCTION INDICATOR LAMP), MISFIRE, ROUGH IDLE, LACK OF POWER AND EVENTUALLY ENGINE STALL IF DRIVEABILITY AND MIL ARE IGNORED.
Safety Risk
No risk description available.
Remedy
EVAPORATIVE EMISSION CANISTER VENT SOLENOID VALVE ASSEMBLY WILL BE RELOCATED TO A PROTECTED AREA. REAR HEATER, VENTILATION AND AIR CONDITIONING EQUIPPED VEHICLES WILL HAVE A SHIELD INSTALLED UNDER THE ASSEMBLY.
17,225 vehicles affectedMfr ref: 98008Updated June 10, 2026
On certain vehicles, the bolts that attach the electric power steering assist motor to the steering gear may corrode and break. This could cause a loss of power steering assist.
Safety Risk
A loss of power steering assist may result in a sudden increase in steering effort, especially at low vehicle speeds. This could increase the risk of a crash.
Remedy
General Motors will notify owners by mail and instruct you to take your vehicle to a dealer to replace the bolts that attach the electric power steering motor and apply a protective wax coating. If the bolts cannot be removed due to corrosion, the steering gear will be replaced.
3,715 vehicles affectedMfr ref: N202301950Updated June 10, 2026
On certain motorcycles, the fuel level sensor float arm holder could deform and allow the arm to separate from the fuel level sensor body. If the float arm separates from the sensor body, the fuel meter would provide inaccurate information. In some cases the separated metal float arm could contact both the positive and negative terminals at the base of the fuel pump, causing a short that results in a blown (fuel injection, ignition or main) fuse. Either symptom could result in an engine stall, which could increase the risk of a crash causing injury and/or damage to property.
Safety Risk
No risk description available.
Remedy
Dealers will replace the fuel level sensor assembly.
3,376 vehicles affectedMfr ref: MK15Updated June 10, 2026
Certain vehicles were equipped with a center high-mount stop light assembly that could short circuit and cause a loss of brake lights. This could increase the risk of a crash causing injury and/or damage to property. In addition, a vehicle with this condition cannot be restarted once it is turned off.
Safety Risk
No risk description available.
Remedy
The company will replace the center high-mount stop light assembly.
141 vehicles affectedMfr ref: AL48Updated June 10, 2026
On certain vehicles, the Automatic Tensioning System (ATS) cable of the seatbelt retractors could fail. Should this occur, the webbing spooled out by the user would not retract. If the spool cable were to break while the belt is being worn, the belt would function normally in a crash. It would then be obvious to the occupant that the belt needs repair as soon as possible.
Safety Risk
No risk description available.
Remedy
Dealers will replace the driver's seatbelt retractor.
665 vehicles affectedMfr ref: 09273Updated June 10, 2026
On certain motorcycles, the connector plug supplying power to the headlight might not be fully installed onto the prongs of the bulb. This could cause the plug to become dislodged from the headlight, resulting in a loss of forward lighting. Loss of forward lighting can create the potential for an accident resulting in injury or death.
Safety Risk
No risk description available.
Remedy
Dealer will ensure that the connector is installed fully onto the back of the headlight bulb.
50 vehicles affectedMfr ref: MC 03-04Updated June 10, 2026
THE PLASTIC BUSHING OF THE CONTROL PRESSURE LINKAGE OF THE AUTOMATIC TRANSMISSION MAY DEFORM AND PREVENT THE THROTTLE LEVER FROM RETURNING TO THE IDLE POSITION.
On certain vehicles, the left-front axle shaft may not have been heat treated, and could break. If this happens, there would be a loss of power to the wheels. Also, if this happens and the vehicle is parked without the parking brake applied, the vehicle could roll away.
Safety Risk
A loss of power to the wheels or a vehicle rollaway could increase the risk of a crash.
Remedy
Kia will notify owners by mail and instruct you to take your vehicle to a dealer to inspect the left front axle shaft for a heat treatment code. If the heat treatment code is missing, the driveshaft will be replaced.
359 vehicles affectedMfr ref: RC136Updated June 10, 2026
On certain vehicles equipped with an optional factory trailer tow hitch package, the trailer tow hitch may have been incorrectly assembled to the vehicle structure. If operated under this condition, this could cause a partial or complete separation of the trailer tow hitch which would increase the risk of crash causing injury and/or damage to property.
Safety Risk
No risk description available.
Remedy
Dealers will inspect and install any missing fasteners to the trailer tow hitch assembly.
1,034 vehicles affectedMfr ref: S62Updated June 10, 2026
On certain vehicles, a fuse can overheat and damage the fuse box, causing a partial loss of exterior vehicle lighting. This could increase the risk of a crash causing injury and/or damage to property.
Safety Risk
No risk description available.
Remedy
Dealers will install a fuse of an updated design.
19,349 vehicles affectedMfr ref: 97AM/3VUpdated June 10, 2026
NOTE: 4X4 VEHICLES.
IF THE VEHICLE IS SUBJECTED TO REAR AXLE LOADING WHICH EXCEEDS THE GROSS AXLE WEIGHT RATING, THE REAR LEAF SPRINGS MAY BE OVERSTRESSED RESULTING IN A POSSIBLE SPRING FATIGUE FRACTURE. A FRACTURED SPRING LEAF COULD SPLAY INWARD AND CONTACT THE FUEL TANK RESULTING IN POSSIBLE FUEL LEAKAGE. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Safety Risk
No risk description available.
Remedy
REAR SPRINGS WILL BE INSPECTED AND AN ADDITIONAL CLIP WILL BE INSTALLED ON THE FORWARD END OF THE REAR SPRINGS TO PREVENT FUEL TANK CONTACT IN THE EVENT OF A LEAF FRACTURE. ALL FRACTURED SPRINGS WILL BE REPLACED.
43,825 vehicles affectedMfr ref: 98S18Updated June 10, 2026
On certain HD model trucks equipped with an Allison A1000 Transmission, the dash display may not indicate the selected gear if the transmission shift lever is in the "1" position. If the driver is not aware of the position of the shift lever and attempts to accelerate only in first gear, it could increase the possibility of a crash without prior warning, which could result in properly damage and/or personal injury.
Safety Risk
No risk description available.
Remedy
Dealers will reflash the transmission control module.
6 vehicles affectedMfr ref: 13442Updated June 10, 2026
Certain sport utility vehicles. The onboard vapor recovery system vent hose may have been misrouted. This could allow water to enter the canister, which can cause fuel to spill out of the filler tube when refueling the tank. Fuel leakage in the presence of an ignition source could result in a fire.
Safety Risk
No risk description available.
Remedy
dealers will inspect (and reposition as necessary) the vent hose. If the vent hose is found in the bent down position, and the vehicle has been driven more than 30 kilometers, the canister assembly will be replaced.
1,877 vehicles affectedMfr ref: AO2Updated June 10, 2026
On certain trucks, the electric fuel heater could overheat. As a result, the fuel heater housing could melt, and fuel could leak into the connector. If this happens, the connection terminals could overheat and melt.
Note: This problem could cause the engine not to start or to have trouble starting.
Safety Risk
A fuel leak and/or a connector that overheats and melts can increase the risk of a fire.
Remedy
Isuzu will notify owners by mail and advise you to take your truck to a dealership to replace the electric fuel heater. The dealer will also inspect and, if necessary, repair any damaged connector.
497 vehicles affectedMfr ref: V2504Updated June 10, 2026
On certain trucks, the castle nut connecting the steering arm to the drag link may not have been tightened properly. As a result, the nut could loosen and separate, causing a loss of steering control.
Safety Risk
A loss of steering control could create the risk of a crash.
Remedy
Volvo Trucks will notify owners by mail and advise you to take your truck to a dealership to inspect and re-tighten the castle nut.
238 vehicles affectedMfr ref: RVXX2311Updated June 10, 2026
