2,070 of 25,867 recalls from Transport Canada and NHTSA.
On certain motorcycles, the fuel pump O-ring may have been twisted during installation and may not seal properly. This could result in a fuel leak, which in the presence of an ignition source, could increase the risk of fire causing injury and/or damage to property.
No risk description available.
Dealers will replace the fuel pump O-ring and fuel tank inner vessel with improved parts.
VEHICLE DESCRIPTION: MINIVANS WHICH WERE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING HOT WEATHER STATES: ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA (10 SOUTHERN COUNTIES), FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA (CLARK COUNTY ONLY), OKLAHOMA, SOUTH CAROLINA AND TEXAS, CAN DEVELOP CRACKS IN THE FUEL TANK IN THE FORWARD STRAP AREA OF THE STANDARD 20 GALLON TANK DUE TO A COMBINATION OF FACTORS THAT ARE PRESENT IN CERTAIN VERY HOT AREAS OF THE COUNTRY.
THESE CRACKS COULD RESULT IN FUEL LEAKAGE IF THEY PROPAGATE THROUGH THE WALL OF THE TANK.
DEALERS WILL INSTALL A BRACE ASSEMBLY AT THE STRAP BOLT HOLE LOCATION AND REPLACE THE TANK STRAP WITH A REVISED, LONGER STRAP. DEALERS WILL ALSO INSPECT THE TANKS FOR LEAKS. IF A LEAK EXISTS AND IS THE RESULT OF A CRACK IN THE FUEL TANK, THE TANK WILL BE REPLACED IN ADDITION TO THE INSTALLATION OF A SPACER AND LONGER STRAP.
On certain vehicles, the potential exists, following disconnection, for the quick connector not to be fully re-engaged. This would eventually result in a loss of fuel that, in the presence of an ignition sources, creates a risk of a vehicle fire. Disconnection is a requirement for some service operations.
No risk description available.
Dealer will remove the quick release collar, ensure full engagement and fit a safety clip.
On certain scooters, wire terminals in the fuel pump wire coupler may corrode due to water infiltration into the main wire harness. This could cause the engine to stall which, in conjunction with traffic and road conditions, and the rider's reactions, could increase the risk of a crash, causing personal injury or death.
No risk description available.
Dealers will install a sub-harness assembly designed to allow any water between the wire harness and the fuel pump to drain out before reaching the pump. If either the main wire harness connector or the fuel pump connector is already corroded, the corresponding assembly(ies) will be replaced.
KYMCO USA (KYMCO) is recalling certain 2018 Like 200i motorcycles. The fuel line clamp may loosen allowing fuel to leak.
A fuel leak in the presence of an ignition source can increase the risk of a fire.
KYMCO will notify owners and dealers will inspect and correct the fuel line clamp tightness, free of charge. The recall began March 19, 2019. Owners may contact KYMCO customer service at 1-888-909-6301.
Jaguar Land Rover North America, LLC (Jaguar) is recalling certain 2010 XF vehicles equipped with 4.2L engines. The fuel tank outlet flange may crack, allowing fuel to leak.
A fuel leak in the presence of an ignition source may increase the risk of a fire.
Jaguar will notify owners, and dealers will replace the fuel outlet flange, free of charge. The recall began June 29, 2020. Owners may contact Jaguar customer service at 1-800-452-4827. Jaguar's number for this recall is H283.
On certain motorcycles, the fuel line quick connectors may break if care is not used when removing the fuel tank at the time of service. A fuel leak, in the presence of an ignition source, could result in a fire.
No risk description available.
Dealers will replace the fuel line quick connectors.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019 Camry Hybrid and Avalon Hybrid vehicles. The fuel filler pipe may not have been properly reconnected to the fuel tank during an inspection after vehicle assembly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 301, "Fuel System Integrity."
The improperly connected filler pipe may leak fuel, which, in the presence of an ignition source can increase the risk of a fire.
Toyota will notify owners, and dealers will inspect the fuel filler pipe, replacing it if necessary, free of charge. The recall began March 19, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is K0I.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019 Camry Hybrid and Avalon Hybrid vehicles. The fuel filler pipe may not have been properly reconnected to the fuel tank during an inspection after vehicle assembly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 301, "Fuel System Integrity."
The improperly connected filler pipe may leak fuel, which, in the presence of an ignition source can increase the risk of a fire.
Toyota will notify owners, and dealers will inspect the fuel filler pipe, replacing it if necessary, free of charge. The recall began March 19, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is K0I.
On certain vehicles, the fuel filler vent tube may not be properly connected. As a result, the tube could loosen or detach and create a fuel leak in a crash.
A fuel leak can create the risk of a fire.
Ford will notify owners by mail and instruct you to take your vehicle to a dealer to install a locking clip on the fuel vapour line.
On certain vehicles, the connections on the fuel supply hose may not be properly attached. As a result, fuel could leak in the engine compartment.
A fuel leak can create the risk of a fire.
Mercedes-Benz will notify owners by mail and instruct you to take your vehicle to a dealer to check the upper and lower connections on the fuel transition hose. The dealer will replace the clamps and the fuel hose, if required.
On certain motorcycles, the fuel tank breather hose may have been kinked during assembly. This could result in fuel flow through the breather hose to be obstructed and the fuel tank internal pressure could become abnormally high or low, causing deformation of the fuel tank, or in some cases could lead to a crack in the fuel tank. If the fuel tank develops a crack, fuel leakage can occur, which in the presence of an ignition source, could result in a fire.
No risk description available.
Dealers will inspect and replace the fuel tank breather hose. If the inspection shows that there was obstructed flow through the breather hose caused by a kink in the hose, the fuel tank will also be replaced.
General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Silverado HD, and GMC Sierra HD vehicles manufactured February 11, 2014, through February 19, 2014, and equipped with diesel engines and dual fuel tanks. In the affected vehicles, the fuel pipe connections on both sides of the diesel fuel transfer pump may not be properly torqued which may result in a diesel fuel leak.
A fuel leak in the presence of an ignition source may result in a vehicle fire.
GM will notify owners, and dealers will tighten the fuel pipe connections to the proper torque. The recall began on May 29, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-462-8782 (GMC). General Motors' number for this recall is 14067.
On certain vehicles, the wiring harness to the fuel pressure sensor may be too short. As a result, the sensor could dislodge or separate from the fuel tank in a rear crash and cause a fuel leak.
A fuel leak can create the risk of a fire.
Volkswagen will notify owners by mail and advise you to take your vehicle to a dealership to install an extension for the fuel pressure sensor wiring harness.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 4.6L ENGINES. SOME OF THESE VEHICLES HAS MISSING OR INADEQUATE BRAZE JOINTS BETWEEN THE FUEL RAIL BODY AND THE FUEL RAIL MOUNTING BRACKET(S).
IF THE BRACKET SEPARATES FROM THE RAIL, THE RAIL CAN LIFT ONE OR MORE OF THE INJECTORS, AND FUEL LEAKAGE WILL RESULT. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
DEALERS WILL REPLACE THE FUEL RAIL ON THESE VEHICLES.
VEHICLE DESCRIPTION: MINI VANS ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA (10 SOUTHERN COUNTIES OF LOS ANGELES, ORANGE, SAN BERNADINO, SAN DIEGO, RIVERSIDE, VENTURA, SANTA BARBARA, SAN LUIS OBISPO, IMPERIAL, AND KERN), FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA (CLARK COUNTY), OKLAHOMA, SOUTH CAROLINA, AND TEXAS, AND IN THE U.S. TERRITORIES COVERED BY THE FEDERAL STATUTES. THE UPPER PORTION OF THE FUEL TANK CAN DEVELOP SMALL CRACKS DUE TO EXTENDED EXPOSURE TO VERY HIGH AMBIENT TEMPERATURES. FUEL VAPOR OR LEAKAGE COULD OCCUR AT THESE CRACKS.
IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.
DEALERS WILL REPLACE THE FUEL TANK, REGARDLESS OF MILEAGE, THROUGH MARCH 31, 2002. THIS COVERAGE WILL ONLY BE FOR STRUCTURAL CRACKS AT THE TOP OF THE TANK AND WILL NOT INCLUDE OTHER DAMAGE CAUSED BY AN ACCIDENT OR ROAD DEBRIS.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2007-2012 Audi Q7 and 2009-2012 Audi Q5 vehicles, previously repaired under NHTSA recall 16V-660. These vehicles were previously repaired with an interim repair of installing butyl tape to the fuel pump flange, until replacement remedy parts became available.
The butyl tape may not prevent fuel from leaking. A fuel leak in the presence of an ignition source can increase the risk of a fire.
Volkswagen will notify owners, and dealers will replace the fuel pump flange and install butyl tape, free of charge. The recall began December 28, 2018. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 20BJ.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2007-2012 Audi Q7 and 2009-2012 Audi Q5 vehicles, previously repaired under NHTSA recall 16V-660. These vehicles were previously repaired with an interim repair of installing butyl tape to the fuel pump flange, until replacement remedy parts became available.
The butyl tape may not prevent fuel from leaking. A fuel leak in the presence of an ignition source can increase the risk of a fire.
Volkswagen will notify owners, and dealers will replace the fuel pump flange and install butyl tape, free of charge. The recall began December 28, 2018. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 20BJ.
JAGUAR IS RECALLING CERTAIN MODEL YEAR 2010 VEHICLES. THE FUEL TRANSFER PIPE IN THE FUEL TANK MAY BE KINKED. THIS MAY RESTRICTS FUEL BEING TRANSFERRED FROM ONE SIDE OF THE FUEL TANK TO THE FUEL PUMP CAUSING FUEL STARVATION AT LOW FUEL LEVELS.
FUEL STARVATION TO THE ENGINE CAN CAUSE THE ENGINE TO STALL WITHOUT WARNING AND COULD POTENTIALLY CAUSE A CRASH.
DEALERS WILL HAVE THE FUEL TANK ASSEMBLY REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 30, 2009. OWNERS MAY CONTACT JAGUAR AT 1-800-452-4827.
On certain vehicles, the fuel pump retaining tabs holding the fuel lines were damaged during production. Over time, this could cause the fuel lines to loosen from the pump resulting in fuel leakage. If an ignition source were present, the fuel may ignite resulting in a vehicle fire.
No risk description available.
Dealers will install a bracket that will secure the fuel lines to the fuel pump even if the plastic retaining tabs should break.
We may earn a commission for purchases made through these links.
