VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES WERE BUILT WITH HOOD HINGE PIVOT BOLTS WHICH CAN BREAK DUE TO AN IMPROPER HEAT TREAT CONDITION. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 219, "WINDSHIELD ZONE INTRUSION." A BROKEN BOLT CAN CAUSE EITHER THE CORNER OF THE HOOD NEAR THE WINDSHIELD TO RAISE, OR ONE SIDE OF THE HOOD TO BE UNSTABLE WHEN OPENED.
Safety Risk
IN THE EVENT OF A VEHICLE CRASH, THE HOOD COULD BE PUSHED BACK THROUGH THE WINDSHIELD GLASS POSSIBLY INJURING THE VEHICLE OCCUPANTS.
VOLVO IS RECALLING 7 MY 2008 V50 PASSENGER VEHICLES EQUIPPED WITH ROOF RAILS. BOLTS HAVE BEEN FOUND TO BE OUT OF SPECIFICATION. THIS HAS CAUSED LESS TREAD LENGTH ON THE BOLTS WHICH IN TURN HAS LEAD TO INSUFFICIENT CLAMPING FORCE IN THE JOINT DUE TO THE WASHER GETTING STUCK WHEN TIGHTENING THE BOLTS.
Safety Risk
WHEN CARRYING ROOF CARGO, THE RAILS MAY COME LOOSE DURING HEAVY BRAKING AND/OR SUDDEN STOPS INCREASING THE POSSIBILITY OF A CRASH.
Remedy
DUE TO THE LIMITED NUMBER OF VEHICLES INVOLVED, OWNERS HAVE BEEN NOTIFIED AND WILL HAVE THE ROOF RAIL BOLTS REPLACED FREE OF CHARGE. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
THESE VEHICLES COULD HAVE BEEN PRODUCED WITH AN IMPROPERLY ADJUSTED SECONDARY HOOD LATCH. THIS DOES NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 113, "HOOD LATCH SYSTEM."
Safety Risk
CONSEQUENCE OF NON-COMPLIANCE: IF THE SECONDARY LATCH IS NOT PROPERLY ENGAGED AND THE PRIMARY HOOD LATCH WAS ALSO NOT ENGAGED, THE HOOD LATCH WAS ALSO NOT ENGAGED, THE HOOD COULD OPEN UNEXPECTEDLY. IF THIS WERE TO OCCUR WHILE THE VEHICLE IS IN MOTION, THE HOOD CAN CONTACT THE WINDSHIELD REDUCING THE VISION OF THE DRIVER AND INCREASING THE RISK OF A VEHICLE ACCIDENT.
Ford Motor Company (Ford) is recalling certain 2016 Focus and C-Max vehicles. The floor pan may have improperly welded left-hand apron joints.
Safety Risk
Improperly welded apron joints may reduce the front-end structural integrity of the vehicle, increasing the risk of injury in the event of a crash.
Remedy
Ford will notify owners, and dealers will inspect the apron joints, repairing the vehicle, as necessary, free of charge. The recall began March 8, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S03.
17 vehicles affectedMfr ref: 17S03Updated June 10, 2026
Ford Motor Company (Ford) is recalling certain 2016 Focus and C-Max vehicles. The floor pan may have improperly welded left-hand apron joints.
Safety Risk
Improperly welded apron joints may reduce the front-end structural integrity of the vehicle, increasing the risk of injury in the event of a crash.
Remedy
Ford will notify owners, and dealers will inspect the apron joints, repairing the vehicle, as necessary, free of charge. The recall began March 8, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S03.
17 vehicles affectedMfr ref: 17S03Updated June 10, 2026
BMW of North America, LLC (BMW) is recalling certain 2024 XM vehicles. The tailgate panel may detach from the mounting structure due to improper adhesive bonding that occurred during manufacturing.
Safety Risk
A panel that detaches from a vehicle can become a road hazard, increasing the risk of a crash.
Remedy
Dealers will inspect and replace the tailgate panel as necessary, free of charge. Owner notification letters were mailed April 17, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Tesla, Inc. (Tesla) is recalling certain 2023 Semi vehicles. The door open warning indicator only displays when the vehicle's parking brake is not engaged and the side door is not fully latched. In addition, the door closure warning system allows the operator to dismiss the notification that the side door is unlatched, which could result in driving with an unsecured door. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 206, "Door Locks and Door Retention Components."
Safety Risk
An operator may be unaware of an unsecured door and begin driving, increasing the risk of injury to occupants.
Remedy
Tesla has released an over-the-air (OTA) software update, free of charge. All affected vehicles were repaired by June 2023. Owners may contact Tesla customer service at 1-877-798-3752.
Nissan North America, Inc. (Nissan) is recalling certain 2023-2024 Nissan Z vehicles. The connectors for the right-side pedestrian detection sensors may be reversed in the front bumper harness, which can prevent the pop-up engine hood from activating as intended.
Safety Risk
A pop-up engine hood that does not activate in a pedestrian crash can increase the risk of injury.
Remedy
Dealers will replace the front bumper harness, free of charge. Owner notification letters were mailed December 11, 2024. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is R24B6.
4,036 vehicles affectedMfr ref: R24B6Updated June 10, 2026
BMW of North America, LLC (BMW) is recalling certain model year 2014-2015 MINI Cooper and MINI Cooper S Hardtop 2 Door vehicles and 2015 MINI John Cooper Works Hardtop 2 Door vehicles. The affected vehicles do not meet the side impact performance requirements for the rear seat passengers. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) number 214, "Side Impact Protection."
Safety Risk
If the side impact performance requirements are not met, rear seat passengers may be at a higher risk of injury during a crash.
Remedy
MINI will notify owners, and dealers will install additional energy absorption material between the rear interior side panels and the exterior vehicle body, free of charge. The recall began on September 4, 2015. Owners may contact MINI customer service at 1-866-825-1525. Note: this recall supersedes 14V-815.
BMW of North America, LLC (BMW) is recalling certain model year 2014-2015 MINI Cooper and MINI Cooper S Hardtop 2 Door vehicles and 2015 MINI John Cooper Works Hardtop 2 Door vehicles. The affected vehicles do not meet the side impact performance requirements for the rear seat passengers. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) number 214, "Side Impact Protection."
Safety Risk
If the side impact performance requirements are not met, rear seat passengers may be at a higher risk of injury during a crash.
Remedy
MINI will notify owners, and dealers will install additional energy absorption material between the rear interior side panels and the exterior vehicle body, free of charge. The recall began on September 4, 2015. Owners may contact MINI customer service at 1-866-825-1525. Note: this recall supersedes 14V-815.
BMW of North America, LLC (BMW) is recalling certain model year 2014-2015 MINI Cooper and MINI Cooper S Hardtop 2 Door vehicles and 2015 MINI John Cooper Works Hardtop 2 Door vehicles. The affected vehicles do not meet the side impact performance requirements for the rear seat passengers. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) number 214, "Side Impact Protection."
Safety Risk
If the side impact performance requirements are not met, rear seat passengers may be at a higher risk of injury during a crash.
Remedy
MINI will notify owners, and dealers will install additional energy absorption material between the rear interior side panels and the exterior vehicle body, free of charge. The recall began on September 4, 2015. Owners may contact MINI customer service at 1-866-825-1525. Note: this recall supersedes 14V-815.
General Motors LLC (GM) is recalling certain 2025 Chevrolet Express and GMC Savana vans. The impact beam located in the driver's side door may have improper welds.
Safety Risk
An improperly welded door impact beam may not adequately protect occupants in a crash, increasing the risk of injury.
Remedy
Dealers will replace the driver's side door, free of charge. Owner notification letters were mailed March 3, 2025. Owners may contact Chevrolet customer service at 800-222-1020 or GMC customer service at 800-462-8782. GM's recall number for this recall is N242490780.
82 vehicles affectedMfr ref: N242490780Updated June 10, 2026
General Motors LLC (GM) is recalling certain 2025 Chevrolet Express and GMC Savana vans. The impact beam located in the driver's side door may have improper welds.
Safety Risk
An improperly welded door impact beam may not adequately protect occupants in a crash, increasing the risk of injury.
Remedy
Dealers will replace the driver's side door, free of charge. Owner notification letters were mailed March 3, 2025. Owners may contact Chevrolet customer service at 800-222-1020 or GMC customer service at 800-462-8782. GM's recall number for this recall is N242490780.
82 vehicles affectedMfr ref: N242490780Updated June 10, 2026
CERTAIN PICKUP TRUCKS HAVE GALVANIZED-BRAIDED-STEEL TAILGATE SUPPORT CABLES USED TO SUPPORT THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION. OVER TIME THESE CABLES CAN CORRODE AND FRACTURE WHEN LOADS ARE APPLIED TO THEM.
Safety Risk
IF ONE CABLE FRACTURES, THE REMAINING CABLE MAY RETAIN THE TAILGATE IN A HORIZONTAL POSITION. IF BOTH CABLES FRACTURE, THE TAILGATE WOULD DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER. IF ANYONE IS SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED, THEY COULD FALL AND BE INJURED. ON VEHICLES WITHOUT A BUMPER, THE TAILGATE MAY DROP TO A LOWER POSITION.
Remedy
DEALERS WILL REPLACE THE GALVANIZED SUPPORT CABLES WITH STAINLESS STEEL SUPPORT CABLES. IN ADDITION, DEALERS ARE TO INSPECT THE TAILGATE HINGE AND REPLACE IT, IF NECESSARY. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010-2011 COROLLA VEHICLES EQUIPPED WITH A NON-TOYOTA, BLUE TOOTH HANDS FREE DEVICE OR NAVIGATION UNIT AND CERTAIN MODEL YEAR 2011 TOYOTA SIENNA VEHICLES EQUIPPED WITH A NON-TOYOTA, OVERHEAD ENTERTAINMENT SYSTEM AND/OR BLUETOOTH HANDS FREE DEVICE. THERE IS A POSSIBILITY THAT THE FRONT A-PILLAR TRIM PANEL RETENTION CLIP MAY HAVE BEEN DAMAGED DURING THE INSTALLATION OF THE AFTERMARKET ACCESSORY.
Safety Risk
A DAMAGED A-PILLAR TRIM PANEL RETENTION CLIP MAY ALLOW THE TRIM PANEL TO COME LOOSE AND INJURE AN OCCUPANT IN THE EVENT OF A CRASH.
Remedy
DEALERS WILL INSPECT THE A-PILLAR TRIM PANEL RETENTION CLIP AND REPLACE IT IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 30, 2011. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
WATER CAN ENTER THE DOOR LATCH RELEASE CABLE. IF THE VEHICLE IS OPERATED IN BELOW FREEZING TEMPERATURES, THE WATER IN THE DOOR LATCH RELEASE CABLE CAN FREEZE AND CAUSE THE LATCH MECHANISM TO MALFUNCTION.
Safety Risk
THE MALFUNCTION OF THE DOOR LATCH RELEASE CAN RESULT INTHREE DIFFERENT PROBLEMS: 1) THE DOOR WILL NOT BE ABLE TO BE RELATCHED, 2) THEINSIDE DOOR HANDLE CAN BECOME INOPERATIVE, AND 3) THE DOOR COULD APPEAR TO BELATCHED WHEN IT IS NOT, ALLOWING THE DOOR TO OPEN UNEXPECTEDLY IF IT IS JARRED,AND INCREASING THE RISK OF INJURY TO THE ADJACENT SEAT OCCUPANT.
Remedy
REVISED DOOR RELEASE CABLES AND WATER SHIELDS WILL BE INSTALLED.
ON CERTAIN VEHICLES, THE HOLE IN THE SHEETMETAL FRONT BULKHEAD THAT SERVES AS THE BASE AND PIVOT POINT FOR THE HOOD SUPPORT ROD WAS NOT PUNCHED TO SPECIFICATION. THE HOOD SUPPORT ROD MAY FAIL TO HOLD THE HOOD IN POSITION DUE TO INSUFFICIENT STRENGTH.
Safety Risk
IF THE HOOD SUPPORT ROD HOLE FAILS, THE HOOD COULD FALL INCREASING THE RISK OF INJURY.
Remedy
DEALERS WILL INSPECT THE PROP ROD BASE HOLE AND, IF NECESSARY, INSTALL REINFORCEMENT PARTS FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 5, 2007. OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Ford Motor Company (Ford) is recalling certain model year 2013-2014 Escape vehicles manufactured October 5, 2011, through April 10, 2014. Due to an assembly misalignment between the exterior door handle and the door outer panel, the affected vehicles have doors that may be difficult to close or may possibly open while driving.
Safety Risk
A door that opens unexpectedly may result in an unrestrained occupant falling from the vehicle, increasing the risk of injury.
Remedy
Ford will notify owners, and dealers will inspect and correct the mounting of the door handles, as necessary, free of charge. The recall began on May 30, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S03.
581,986 vehicles affectedMfr ref: 14S03Updated June 10, 2026
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. SOME OF THESE VEHICLES HAVE LOOSE OR MISSING REAR WHEELHOUSE PLUGS. UNDER CERTAIN VEHICLE OPERATING CONDITIONS, EXHAUST GASES CAN FLOW FORWARD AND ACCUMULATE IN THE REAR WHEELHOUSE.
Safety Risk
THESE GASES COULD FLOW INTO THE PASSENGER COMPARTMENT IF THE PLUG IS MISSING OR LOOSE AND COULD CAUSE POSSIBLE ILLNESS, UNCONSCIOUSNESS, OR DEATH.
Remedy
DEALERS WILL INSPECT THE VEHICLE FOR LOOSE OR MISSING WHEELHOUSE PLUGS AND INSTALL NEW PLUGS IF NECESSARY.
HONDA IS RECALLING CERTAIN MODEL YEAR 2005 ODYSSEY TOURING VEHICLES EQUIPPED WITH POWER OPERATED REAR LIFTGATE. THE POWER LIFTGATE GAS STRUTS MAY DETERIORATE UNEXPECTEDLY EARLY. STRUTS THAT HAVE WORN OUT PREMATURELY MAY FAIL TO HOLD THE POWER LIFTGATE IN THE FULLY OPEN POSITION, CAUSING THE POWER LIFTGATE TO CLOSE UNEXPECTEDLY.
Safety Risk
INJURY MAY RESULT FROM A POWER LIFTGATE CLOSING UNEXPECTEDLY WHEN A PERSON IS WITHIN THE CLOSING PATH OF THE LIFTGATE.
Remedy
DEALERS WILL INSPECT THE GAS LIFTGATE STRUTS AND REPLACE IF WITHIN THE RECALL POPULATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE CAMPAIGN BEGAN ON MARCH 26, 2010. OWNERS MAY CONTACT HONDA AUTOMOBILE CUSTOMER SERVICE AT 1-800-999-1009.
Also recalled in Canada