Fujian Wanda Automobile Glass Industry (Wanda) is recalling certain aftermarket Replacement Windshields sold for use in 2014-2018 Toyota Highlander vehicles. The windshields have an attached wire harness that water may leak into, possibly causing damage to the vehicle's Engine Control Module (ECM).
Safety Risk
The ECM damage may result in the engine stalling, increasing the risk of a crash.
Remedy
Wanda will notify owners, and service centers will replace the windshields, and inspect the ECM for damage, having it replaced, as necessary, free of charge. The recall began January 29, 2019. Owners may contact Wanda customer service at 1-864-281-2760.
BMW of North America, LLC (BMW) is recalling certain 2019 BMW X5 xDrive40i vehicles. The capacitors within the Body Domain Controller (BDC) may short circuit and overheat.
Safety Risk
If the BDC short circuits, other nearby components may also overheat, increasing the risk of a fire.
Remedy
All affected vehicles remain on dealer lots, therefore owner letters will not be mailed. BMW dealers will replace the BDC control unit, free of charge. The recall began on October 17, 2018. Owners may contact BMW customer service at 1-800-525-7417.
General Motors LLC (GM) is recalling certain 2016-2018 Chevrolet Express and GMC Sierra vehicles equipped with a single, manual, rear climate control module (CCM). If the temperature is set to maximum heat or the mode knob is set to maximum floor vent and an electrical short occurs, components within the CCM may overheat.
Safety Risk
If the CCM overheats, there is an increased risk of a fire in the vehicle's headliner.
Remedy
GM will notify owners, and dealers will remove the electrical insulation from a wiring connector within the CCM to remove the fire risk, free of charge. The recall began November 6, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 18299.
Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2018 Mercedes-Maybach S560 and S560 4Matic and Mercedes S450 4Matic, S450, S560, S560 4Matic, and S560 Coupe 4Matic vehicles. The electrical power bars inside the pre-fuse box in the trunk may not have been secured properly.
Safety Risk
If the power bars are not properly secured, it can cause higher electrical resistance increasing the risk of a fire. Additionally, an intermittent contact between the power bars could lead to a loss of vehicle functions. The engine operation, the seat belt functions and the instrument cluster could be impaired, increasing the risk of a crash and injuries.
Remedy
MBUSA will notify owners, and dealers will inspect the pre-fuse box, replacing it as necessary, free of charge. The recall began August 30, 2018. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2018080001.
Porsche Cars North America, Inc. (Porsche) is recalling certain 2018 Porsche Macan S and Macan vehicles. These vehicles have a control unit that may fail and prevent safety-related functions such as driver display alerts and possibly impair drivability and post-crash functions.
Safety Risk
Failure of the control unit may increase the risk of a crash.
Remedy
Porsche will notify owners, and dealers will replace the affected control unit, free of charge. The recall began July 27, 2018. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AJ05.
Indian Motorcycle Company (Indian) is recalling certain 2018 Indian Chief, Chief Classic, Chief Dark Horse, Chief Vintage, Chieftain, Chieftain Classic, Chieftain Dark Horse, Chieftain Elite, Chieftain Limited, Springfield, Springfield Dark Horse, Roadmaster, Roadmaster Elite, Roadmaster Icon, and Roadmaster Classic motorcycles. Corrosion may develop within the right combination switch, potentially resulting in the motorcycle starting without the user's intent if the key fob is near the motorcycle and the required safety interlock conditions are met.
Safety Risk
If the motorcycle starts unintentionally and is parked in an enclosed space, exposure to carbon monoxide may increase the risk of injury.
Remedy
Indian will notify owners, and dealers will replace the right hand combination switch, free of charge. Owners may contact Indian customer service at 1-877-204-3697. Indian's number for this recall is I-18-04.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010 Lexus HS 250h Hybrid vehicles. A component within the hybrid transaxle assembly may short circuit and result in a reduction or a complete loss of available power for moving the vehicle.
Safety Risk
A complete loss of motive power can increase the risk of a crash.
Remedy
Lexus will notify owners, and dealers will replace the hybrid vehicle transaxle assembly, free of charge. The recall began on December 1, 2017. Owners may contact 1-800-255-3987. Toyota's number for this recall is HLE.
Subaru of America, Inc. (Subaru) is recalling certain model year 2007-2009 model year Legacy and Outback vehicles, 2008-2014 Impreza vehicles and 2009-2013 Forester vehicles, all equipped with turbo-charged engines. The relay that controls the secondary air injection pump may fail, causing the pump to continuously operate and overheat.
Safety Risk
If the air injection pump overheats, it may melt and increase the risk of a fire.
Remedy
Subaru will notify owners, and dealers will replace the secondary air injection pump relay, free of charge. The recall began December 2016. Owners may contact Subaru customer service at 1-800-782-2783. Subaru's number for this recall is WTM-73.
Chrysler (FCA US LLC) is recalling certain model year 2015-2016 Ram ProMaster City vans manufactured September 26, 2014, to March 5, 2016. A low-voltage electrical harness connector by the front driver seat may be susceptible to water intrusion and corrosion. Corrosion may result in a loss of communication to the Transmission Control Module (TCM) and may cause the transmission to unexpectedly shift into and stay in neutral without warning the next time that the vehicle stops.
Safety Risk
An unintended shift into neutral will prevent the vehicle from being moved. Additionally, if the driver turns off the engine, the driver will be unable to restart the engine. Both scenarios can increase the risk of a crash.
Remedy
Chrysler will notify owners, and dealers will relocate the harness connector to under the instrument panel, free of charge. The recall began on June 3, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S24.
Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2008-2012 AN400, AN400A, DL1000, GSX1300R, 2008-2009 GSF1250S and GSF1250SA, 2008 GSX1300BK and GSX1300BKA, 2008-2010 GSX650F, GSX-R600, GSX-R750, VLR1800, VLR1800T, and 2009-2010 SFV650 and VZ1500 motorcycles. Due to a problem with the circuit board for the regulator/rectifier power module, the motorcycle may not sufficiently charge the battery and the motorcycle may stall.
Safety Risk
If the engine stalls while riding, there would be an increased risk of a crash.
Remedy
Suzuki will notify owners, and dealers will replace the regulator/rectifier, free of charge. The recall is expected to begin March 4, 2016. Owners may contact Suzuki customer service at 1-800-444-5077. Suzuki's number for this recall is 2A56 to 2A64.
Mercedes-Benz USA, LLC. (MBUSA) is recalling certain model year 2015 S550 Hybrid vehicles manufactured April 24, 2015, to June 12, 2015. The affected vehicles are equipped with a high voltage onboard charger that may not have been built to specification, and as a result, the charging function for an external charging cable might not function and the onboard charger may incorrectly detect a charging cable, even while the vehicle is being driven.
Safety Risk
If the charging cable is incorrectly detected and the vehicle is stopped or moving at a very slow speed, the vehicle may unexpectedly shift to park, increasing the risk of a crash.
Remedy
MBUSA will notify owners, and dealers will replace the onboard charger, free of charge. The recall began on January 27, 2016. Owners may contact MBUSA customer service at 1-800-367-6372.
Volvo Trucks North America (Volvo) is recalling certain model year 2012-2014 Volvo VNL trucks manufactured December 1, 2011, to September 1, 2013, equipped with certain Electric Auxiliary Power Units (APU), part number BA600, manufactured by Idle Free Systems (IFS). The affected APUs have metal housings whose mounting points may crack and tear. Additionally, the mounting bolts of the power units may loosen or possibly fail.
Safety Risk
If the mounting points crack and tear or the attaching bolts loosen or fail, the power unit may detach from the truck, becoming a road hazard and increasing the risk of a crash.
Remedy
Volvo will notify owners and IFS dealers will inspect the APU for damage and, where needed, install a welded gusset upgrade kit to strengthen the APU C-channels. All units will receive stronger clamping brackets. The recall began on December 10, 2015. Owners may contact Volvo customer service at 1-800-528-6586, or IFS customer service at 1-920-206-9333. Volvo's number for this recall is RVXX1506.
Chrysler (FCA US LLC) is recalling certain model year 2015 Chrysler 200 vehicles manufactured January 7, 2014, to September 23, 2014. The affected vehicles may have a Power Distribution Center (PDC) electrical connector that may cause intermittent power failures to certain electrical components.
Safety Risk
An intermittent loss of power to electrical components could cause a vehicle to stall without warning, increasing the risk of a crash.
Remedy
Chrysler will notify owners, and dealers will replace the C4 connector using a 12 wire split kit for 3.6L engines, or replace the transmission wiring harness for 2.4L engines, free of charge. The recall began on October 21, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R24.
Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2009-2010 Mitsubishi Lancer vehicles manufactured January 12, 2009, to July 6, 2010, 2009-2010 Outlander vehicles manufactured January 12, 2009, to August 27, 2010, 2010 Lancer Sportback vehicles manufactured June 17, 2009, to June 8, 2010, and 2010 Lancer Evolution vehicles manufactured July 14, 2009, to August 4, 2010. The affected vehicles have an electronic control unit (ECU) that controls the head lights, tail lights, and windshield wipers. Due to a manufacturing error, the voltage inside this ECU may be unstable.
Safety Risk
Unstable voltage could result in intermittent failure of the vehicle's head lights, tail lights, and windshield wipers. If the headlights and/or windshield wipers fail, the driver could have reduced visibility. If the tail lights fail, the vehicle could be less visible. Either condition increases the risk of a crash.
Remedy
Mitsubishi will notify owners, and dealers will replace the affected ECU, free of charge. The recall began on June 15 ,2015. Owners may contact Mitsubishi customer service at 1-888-648-7820. Mitsubishi's number for this recall is SR-15-002.
Ford Motor Company (Ford) is recalling certain model year 2013-2015 Lincoln MKT vehicles with a limousine or hearse preparation package, manufactured March 6, 2012, to March 10, 2015. In the affected vehicles, the vacuum pump relay may overheat due to an internal fault or contamination.
Safety Risk
If the vacuum pump relay overheats, there is an increased risk of a vehicle fire.
Remedy
Ford will notify owners, and dealers will replace the vacuum pump relay with a new electro-mechanical relay, free of charge. The recall began on July 6, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S10.
Chrysler (FCA US LLC) is recalling certain model year 2012-2013 Jeep Grand Cherokee vehicles manufactured September 17, 2010, to August 19, 2013, and equipped with a 3.6, 5.7 or 6.4 liter engine, and 2012-2013 Dodge Durango vehicles manufactured January 18, 2011, to August 19, 2013, and equipped with a 3.6 or 5.7 liter engine. In the affected vehicles, the fuel pump relay inside the Totally Integrated Power Module (TIPM-7) may fail, causing the vehicle to stall without warning.
Safety Risk
A vehicle stall increases the risk of a crash.
Remedy
Chrysler will notify owners, and dealers will replace the fuel pump relay with one external to the TIPM. The recall began on August 7, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R09. Note: This recall is an expansion of recall 14V-530. Note: This recall has been superseded by recall 19V813.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2011-2012 Toyota Avalon vehicles manufactured February 9, 2010, to October 22, 2012. In the affected vehicles, the sub-woofer speaker located in the trunk may experience an intermittent electrical short which may cause damage to the integrated circuit (IC) in the audio amplifier. In some cases, the damaged IC may allow a constant electrical current flow to the sub-woofer.
Safety Risk
A constant electrical current flow may cause the sub-woofer to overheat, increasing the risk of fire.
Remedy
Toyota will notify owners, and dealers will replace the audio system amplifier and install a protective cover around the sub-woofer, free of charge. The recall began on July 1,2015. Owners may contact Toyota customer service at 1-888-270-9371.
Nissan North America, Inc. (Nissan) is recalling certain model year 2008-2013 Nissan Rogue vehicles manufactured March 7, 2007, to November 26, 2013, and 2014 Nissan Rogue Select vehicles manufactured September 23, 2013, to July 2, 2014. The affected vehicles may experience an electrical short in the harness connector due to a mixture of snow/water and salt seeping through the carpet on the driver side floor near the harness connector.
Safety Risk
An electrical short can cause a vehicle fire.
Remedy
Nissan will notify owners, and dealers will inspect the kick panel wiring harness connector and will if necessary install a new harness connector and waterproof seal, free of charge. The recall began on February 26, 2015. Owners may contact Nissan customer service at 1-800-647-7261.
Kia Motors America (Kia) is recalling certain model year 2014 Kia Forte vehicles manufactured December 5, 2012, to April 17, 2014. In the affected vehicles, the cooling fan resistor may overheat and melt.
Safety Risk
If the cooling fan resistor overheats and melts, there is an increased risk of a vehicle fire.
Remedy
Kia will notify owners, and for vehicles produced from December 5, 2012 to January 27, 2014, dealers will replace the cooling fan resistor and multi-fuse unit. For vehicles produced from January 28, 2014 to April 17, 2014, dealers will replace the multi-fuse unit only. Owners of vehicles with a 1.8L engine will also have the engine control unit software updated. The recall began on February 20, 2015. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC113.
General Motors LLC (GM) is recalling certain model year 2013-2014 Cadillac CTS, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL, and 2014 Buick Enclave, Chevrolet Express, Impala, Silverado HD, Traverse, GMC Acadia, Savana, and Sierra HD vehicles. In the affected vehicles, the chassis electronic module may be internally contaminated, resulting in an electrical short.
Safety Risk
If the module experiences an electrical short, the vehicle could stall, increasing the risk of a crash.
Remedy
GM will notify owners, and dealers will replace the chassis electronic module, free of charge. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-006 (Cadillac), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GMs number for this recall is 14515.
Also recalled in Canada