SOME SPORT UTILITY VEHICLES EQUIPPED WITH AN ELECTRONICALLY CONTROLLED AIR SUSPENSION (ECAS) HAVE A CONDITION IN WHICH THE ECAS MAY PRODUCE A BRIEF ELECTRICAL SPIKE WHILE THE VEHICLE IS OPERATING. THIS ELECTRICAL SPIKE CAN DISRUPT THE POWERTRAIN CONTROL MODULE (PCM) CAUSING THE VEHICLE TO STALL.
Safety Risk
IF THE SPIKE DAMAGES THE PCM, THE VEHICLE MAY NOT RESTART. IF THIS HAPPENS WHILE THE VEHICLE IS MOVING, A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy
DEALERS WILL INSTALL A WIRING HARNESS. THE RECALL WILL BEGIN ON AUGUST 19, 2004. OWNERS SHOULD CONTACT OLDSMOBILE AT 1-800-630-6537 OR GMC AT 1-866-996-9463.
ON CERTAIN HEAVY-DUTY CLASS 8 TRUCKS, THE ASSEMBLED ENGINE PRE-HEATER JUMPER WIRING HARNESS WAS INCORRECTLY ASSEMBLED.
Safety Risk
THE ENGINE PRE-HEATER COULD OVERHEAT RESULTING IN DAMAGE TO THE PRE-HEATER AND OTHER ENGINE HEAT SENSITIVE COMPONENTS NEAR THE PRE-HEATER AND THE ABILITY TO RE-START THE ENGINE COULD BE COMPROMISED, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL REPAIR THE AFFECTED CIRCUITS IN THE JUMPER WIRING HARNESS CONNECTOR. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MARCH 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
ON CERTAIN ELECTRIC VEHICLES, THE FRONT SUSPENSION TRANSVERSE LINK'S BALL JOINT BRACKET MAY BREAK FROM STRESS CONCENTRATION AT A NOTCH CREATED BY SURFACE ROUGHNESS AND THE SHAPE OF THE MATERIAL CUT-LINE.
Safety Risk
No risk description available.
Remedy
DEALERS WILL REPLACE THE BRACKET ON THESE VEHICLES. OWNER NOTIFICATION BEGAN DECEMBER 15, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.
ON CERTAIN PASSENGER VEHICLES, THE CIRCUIT BOARD FOR THE CRANK POSITION SENSOR OR CAM POSITION SENSOR MAY HAVE AN IMPROPER SOLDER JOINT DUE TO SOLDER DEFORMATION CAUSED BY HEAT STRESS ACCELERATED BY THE EXISTENCE OF FLUX RESIDUE DURING THE SOLDERING PROCESS.
Safety Risk
THIS COULD CAUSE THE "SERVICE ENGINE SOON" WARNING LIGHT TO COME ON, CREATE A NO START CONDITION, CAUSE REDUCED ENGINE POWER, OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING DURING VEHICLE OPERATION, WHICH COULD RESULT IN A CRASH.
Remedy
DEALERS WILL REPLACE THE CRANK POSITION SENSORS. CAMSHAFT POSITION SENSOR(S), AND IN SOME CASES, THE VARIABLE TIMING CONTROL SENSOR(S). VEHICLES INVOLVED IN A PREVIOUS RECALL CAMPAIGN, 01V357, ARE ALSO INCLUDED IN THIS NEW CAMPAIGN. THE REPLACEMENT SENSORS USED IN THAT CAMPAIGN ARE ALSO AFFECTED. OWNER NOTIFICATION BEGAN ON DECEMBER 22, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261 OR INFINITI AT 1-800-662-6200.
ON CERTAIN PASSENGER VEHICLES, THE ENGINE OIL FILTER DRAIN PLUG MAY BE INSUFFICIENTLY TIGHTENED. THIS COULD LEAD TO LOOSENING OF THE PLUG CAUSING AN INITIAL OIL SPRAY AND A SUBSEQUENT OIL LEAK.
Safety Risk
IF A LARGE AMOUNT OF OIL LOSS OCCURS, ENGINE DAMAGE MAY RESULT. DEPENDING ON THE EXTENT OF THE DAMAGE, A CRASH COULD OCCUR.
Remedy
DEALERS WILL INSPECT THE TORQUE OF THE OIL FILTER DRAIN PLUG AND, IF NECESSARY, RETIGHTEN THE DRAIN PLUG WITH THE CORRECTLY SPECIFIED TORQUE. OWNER NOTIFICATION BEGAN ON SEPTEMBER 12, 2003. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
ON CERTAIN PASSENGER VEHICLES, DUE TO A SOFTWARE ERROR, A DESYNCHRONIZATION OF THE VALVETRONIC MOTORS FOR ENGINE BANKS I AND II MAY OCCUR. IF THIS OCCURS, THE ENGINE COULD STALL.
Safety Risk
IN THOSE CASES, THE DRIVER MAY NOT BE ABLE TO RESTART THE ENGINE. DEPENDING ON THE LEVEL OF ENGINE ROUGHNESS, OR STALLING, AS WELL AS TRAFFIC CONDITIONS AND THE DRIVER'S REACTIONS, THIS COULD LEAD TO A CRASH.
Remedy
DEALERS WILL REPROGRAM THE DIGITAL ENGINE MANAGEMENT CONTROL UNIT. OWNER NOTIFICATION BEGAN JULY 8, 2003. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
VEHICLE DESCRIPTION: 1995 PASSENGER VEHICLES EQUIPPED WITH THE 2.0L AND 2.5L ENGINES, AND 1996 VEHICLES EQUIPPED WITH 2.5L ENGINES. TIGHTENING OF THE ENGINE COOLING FAN MOTOR BEARINGS, UP TO AND INCLUDING MOTOR STALL, CAN RESULT IN INCREASED MOTOR TORQUE AND HIGHER THAN NORMAL MOTOR CURRENT AND ACCOMPANYING HIGH MOTOR TEMPERATURES.
Safety Risk
OVERHEATING OF THE COOLING FAN MOTOR DUE TO EXCESSIVE CURRENT CAN RESULT IN SMOKE AND ODORS FROM BEARING GREASE, INSULATION AND OTHER INTERNAL MOTOR COMPONENTS. IF ELECTRICAL CURRENT CONTINUES TO BE APPLIED TO THE MOTOR, INTERNAL MOTOR COMPONENTS COULD IGNITE POSSIBLY IGNITING OTHER ENGINE COMPARTMENT COMPONENTS.
Remedy
DEALERS WILL INSTALL A POSITIVE TEMPERATURE COEFFICIENT DEVICE IN-LINE WITH EACH FAN MOTOR. FORD WILL ALSO EXTEND THE WARRANTY ON THE ENGINE COOLING FAN ASSEMBLY TO A TOTAL OF 8 YEARS OF SERVICE OR 100,000 MILES FROM THE WARRANTY START DATE, WHICHEVER OCCURS FIRST. IF THE VEHICLE ALREADY HAS MORE THAN 100,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2001.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. AS A RESULT OF WATER INGRESS AND SUBSEQUENT ICE BLOCKAGE, THE TRANSMISSION BREATHER TUBE CAN BECOME CLOGGED, EXPELLING TRANSMISSION FLUID FROM THE DIPSTICK TUBE ONTO HOT ENGINE COMPONENTS.
Safety Risk
THIS LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN RESULT IN AN UNDERHOOD FIRE.
Remedy
DEALERS WILL REMOVE THE TRANSMISSION BREATHER TUBE FROM THE INNER FENDER AND A SECTION OF THE HOSE WILL BE CUT AT AN ANGLE. THIS ACTION WILL REMOVE THE END OF THE BREATHER TUBE FROM ANY POOLED WATER AND WILL ELIMINATE WATER DROPLETS FROM CLINGING TO THE END OF THE TUBE.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. CERTAIN UNDERHOOD HOSE AND TUBING COMPONENTS CAN FAIL ALLOWING FLUID TO LEAK, SUCH AS ENGINE COOLANT, WINDSHIELD WIPER FLUID, AND AUTOMATIC TRANSMISSION FLUID.
Safety Risk
THIS LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN RESULT IN AN UNDERHOOD FIRE.
Remedy
DEALERS WILL INSPECT THESE VEHICLES AND REPLACE THESE COMPONENTS. NOTE THAT NOT ALL COMPONENTS WILL NEED TO BE REPLACED.
Also recalled in Canada