24 of 25,867 recalls from Transport Canada and NHTSA.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH 5.9L - 24 VALVE DIESEL ENGINE. AN INTERMITTENT HIGH ENGINE IDLE CONDITION CAN OCCUR DUE TO A MALFUNCTION OF THE VEHICLE SPEED SENSOR.
THIS CREATES A SIGNAL WHICH IS MISINTERPRETED BY THE ENGINE CONTROL SOFTWARE, CAUSING A HIGH IDLE SPEED CONDITION.
DEALERS WILL REPLACE THE ENGINE CONTROLLER SOFTWARE TO CORRECT ERRONEOUS SPEED SENSOR SIGNALS.
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured July 15, 2015, to April 14, 2016 and equipped with a 3.2L diesel engine. A fuel injector or the fuel volume control valve may clog due to metallic debris within the fuel system.
If debris clogs the fuel system, the engine may stall, increasing the risk of a crash.
Ford will notify owners, and dealers will replace the fuel injection pump and associated parts and, if necessary, will replace the fuel filter and flush the fuel system, free of charge. The recall began on October 14, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S32.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS, VANS AND MOTORHOMES EQUIPPED WITH ELECTRONICALLY FUEL INJECTED 6.5L DIESEL ENGINE. THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH FEDERAL REGULATION PART 573. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. THE CAMPAIGN WILL IMPROVE THE OVERALL DRIVEABILITY OF THESE VEHICLES.
CERTAIN VEHICLES CAN EXHIBIT SOME DRIVEABILITY CONCERNS SUCH AS POOR THROTTLE RESPONSE, STALLING, MISFIRE, POOR HOT OR COLD STARTING, EXTENDED CRANKING OF A HOT ENGINE, OR STALLING AFTER START. TRUCKS WITH MANUALTRANSMISSIONS CAN EXHIBIT POOR ACCELERATION FROM START OR COULD STALL DURING DECELERATION.
DEALERS WILL INSTALL SOME RECENTLY DEVELOPED ENHANCEMENTS WHICH WILL IMPROVE THE OVERALL DRIVEABILITY OF THESE VEHICLES.
Mercedes-Benz USA, LLC (Mercedes) is recalling certain model year 2014-2015 E250 BlueTec, E250 BlueTec 4Matic, GLK250 4Matic BlueTec, and 2015 ML250 4Matic BlueTec vehicles manufactured February 28, 2014, to November 10, 2014. In the affected vehicles, oil may leak from around the chain tensioner gasket area.
Leaking oil may drip onto a hot engine surface, increasing the risk of a fire. Additionally, the leaking oil may be a road hazard for other vehicles, increasing the risk of a crash.
Mercedes will notify owners, and dealers will replace the chain tensioner gasket, free of charge. The recall began on December 19, 2014. Owners may contact Mercedes customer service at 1-800-367-6372. Mercedes' number for this recall is 2014120002.
ON CERTAIN TRANSIT BUSES EQUIPPED WITH CUMMINS WESTPORT B GAS PLUS OR C GAS PLUS 6 CYLINDER ENGINES, THE ELECTRONIC CONTROL MODULE CALIBRATION MAY NOT CORRECTLY DETECT A THROTTLE PLATE ACTUATOR FAILURE THAT COULD RESULT IN AN UNCOMMANDED OPEN THROTTLE CONDITION.
IF THIS EVENT OCCURS, THE VEHICLE OPERATOR WILL NOT HAVE CONTROL OF THE ENGINE SPEED WHICH COULD POSSIBLY RESULT IN A VEHICLE CRASH.
DEALERS WILL REPLACE THE ELECTRONIC CONTROL MODULE CALIBRATION FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CUMMINS CUSTOMER ASSISTANCE CENTER AT 1-800-343-7357 OR VOLVO TRUCK AT 1-800-528-6586.
ON CERTAIN TRUCKS, AN INCORRECT SOFTWARE PARAMETER WAS LOADED WHICH RESULTED IN THE DIESEL PARTICULATE FILTER (DPF) 'INHIBIT' FUNCTION BEING DISABLED. THE 'INHIBIT' FUNCTION IS A MEANS FOR THE DRIVER TO STOP A DPF REGENERATION FROM OCCURRING IF A VEHICLE IS IN A LOCATION THAT MAY PRESENT A HAZARDOUS SITUATION.
IF THE DRIVER BELIEVES THAT REGENERATION HAS BEEN STOPPED WHEN IT HAS NOT, IT COULD RESULT IN A FIRE.
DEALERS WILL CHANGE THE CONTROL PARAMETERS. THE RECALL BEGAN ON FEBRUARY 15, 2008. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
Mercedes-Benz USA, LLC (Mercedes) is recalling certain model year 2015 E250 BlueTec vehicles manufactured November 3, 2014, to December 15, 2014, E250 BlueTec 4Matic vehicles manufactured November 4, 2014, December 17, 2014, GLK250 vehicles manufactured November 13, 2014, to January 30, 2015, and 2015 ML250 BlueTec vehicles manufactured December 12, 2014, to February 9, 2015. In the affected vehicles, oil may leak from around the chain tensioner gasket area.
Leaking oil may drip onto a hot engine surface, increasing the risk of a fire. Additionally, the leaking oil may be a road hazard for other vehicles, increasing the risk of a crash.
Mercedes will notify owners, and dealers will replace the chain tensioner gasket, free of charge. The recall began on June 23, 2015. Owners may contact Mercedes customer service at 1-800-367-6372. Mercedes' number for this recall is 2015050005. Note: This is an expansion of NHTSA recall 14V-762.
Mercedes-Benz USA, LLC (Mercedes) is recalling certain model year 2015 E250 BlueTec vehicles manufactured November 3, 2014, to December 15, 2014, E250 BlueTec 4Matic vehicles manufactured November 4, 2014, December 17, 2014, GLK250 vehicles manufactured November 13, 2014, to January 30, 2015, and 2015 ML250 BlueTec vehicles manufactured December 12, 2014, to February 9, 2015. In the affected vehicles, oil may leak from around the chain tensioner gasket area.
Leaking oil may drip onto a hot engine surface, increasing the risk of a fire. Additionally, the leaking oil may be a road hazard for other vehicles, increasing the risk of a crash.
Mercedes will notify owners, and dealers will replace the chain tensioner gasket, free of charge. The recall began on June 23, 2015. Owners may contact Mercedes customer service at 1-800-367-6372. Mercedes' number for this recall is 2015050005. Note: This is an expansion of NHTSA recall 14V-762.
Mercedes-Benz USA, LLC (Mercedes) is recalling certain model year 2015 E250 BlueTec vehicles manufactured November 3, 2014, to December 15, 2014, E250 BlueTec 4Matic vehicles manufactured November 4, 2014, December 17, 2014, GLK250 vehicles manufactured November 13, 2014, to January 30, 2015, and 2015 ML250 BlueTec vehicles manufactured December 12, 2014, to February 9, 2015. In the affected vehicles, oil may leak from around the chain tensioner gasket area.
Leaking oil may drip onto a hot engine surface, increasing the risk of a fire. Additionally, the leaking oil may be a road hazard for other vehicles, increasing the risk of a crash.
Mercedes will notify owners, and dealers will replace the chain tensioner gasket, free of charge. The recall began on June 23, 2015. Owners may contact Mercedes customer service at 1-800-367-6372. Mercedes' number for this recall is 2015050005. Note: This is an expansion of NHTSA recall 14V-762.
BMW IS RECALLING CERTAIN MODEL YEAR 2011, X5 DIESEL SPORTS ACTIVITY VEHICLES (SAV) MANUFACTURED FROM MARCH 31, 2011, THROUGH MAY 19, 2011. DUE TO A COMPONENT MANUFACTURING ERROR AT THE SUPPLIER, THE WELDS IN THE BELT TENSIONER COULD HAVE INCIPIENT CRACKS. OVER TIME, THIS COULD LEAD A MALFUNCTION OF THE BELT TENSIONER.
IF THE BELT TENSIONER FAILS, THERE COULD BE A SUDDEN LOSS OF POWER STEERING ASSISTANCE, IF POWER STEERING ASSIST IS LOST, MANUAL STEERING CAPABILITY IS STILL RETAINED AND COULD INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE ENGINE BELT TENSIONER FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2011. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417, OR VIA EMAIL AT CUSTOMERRELATIONS@BMWUSA.COM.
Chrysler (FCA US LLC) is recalling certain 2014-2018 Ram 1500 and 2014-2016 Jeep Grand Cherokee vehicles equipped with 3.0L diesel engines. The crankshaft position sensor tone wheel may delaminate causing the engine to lose its ability to synchronize the fuel injector pulses and cam shaft timing, possibly resulting in an engine stall.
An engine stall can increase the risk of a crash.
FCA US will notify owners, and dealers will update the powertrain control module software to maintain vehicle propulsion by reading the camshaft position signal in the event that the crankshaft position signal is lost, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact FCA US customer service at 1-800-853-2002. FCA US's number for this recall is W58.
Chrysler (FCA US LLC) is recalling certain 2014-2018 Ram 1500 and 2014-2016 Jeep Grand Cherokee vehicles equipped with 3.0L diesel engines. The crankshaft position sensor tone wheel may delaminate causing the engine to lose its ability to synchronize the fuel injector pulses and cam shaft timing, possibly resulting in an engine stall.
An engine stall can increase the risk of a crash.
FCA US will notify owners, and dealers will update the powertrain control module software to maintain vehicle propulsion by reading the camshaft position signal in the event that the crankshaft position signal is lost, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact FCA US customer service at 1-800-853-2002. FCA US's number for this recall is W58.
ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.
IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING.
DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH 5.9L - 24 VALVE DIESEL ENGINE. THE LOW PRESSURE DIESEL FUEL SUPPLY TUBE LOCATED IN THE ENGINE COMPARTMENT BETWEEN THE FILTER AND THE HIGH PRESSURE PUMP CAN FRACTURE.
THIS CONDITION CAN ALLOW FUEL TO LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, FUEL LEAKAGE CAN RESULT IN A FIRE.
DEALERS WILL REPLACE THE LOW PRESSURE DIESEL FUEL SUPPLY TUBE.
Mercedes-Benz USA, LLC - DBA Sprinter (Mercedes) is recalling certain model year 2015 Sprinter 2500 and Sprinter 3500 vehicles manufactured February 28, 2014, to January 22, 2015. In the affected vehicles, oil may leak from around the chain tensioner gasket area.
Leaking oil may drip onto a hot engine surface, increasing the risk of a fire. Additionally, the leaking oil may be a road hazard for other vehicles, increasing the risk of a crash.
Mercedes will notify owners, and dealers will replace the chain tensioner gasket, free of charge. The recall began May 18, 2015. Owners may contact Mercedes customer service at 1-877-762-8267. Note: This recall is an expansion of 14V-764.
Volvo Trucks North America (Trucks) is recalling certain model year 2017 VNL trucks manufactured March 15, 2016, to April 20, 2016, equipped with a Cummins ISX12 or ISX15 engine using certain engine control modules (ECM). These ECM's may experience an internal electrical short that can cause a fuse to blow, resulting in an unexpected engine stall without the ability to restart the engine.
An engine stall can increase the risk of a crash.
Cummins will notify owners, and Cummins dealers will replace the existing ECM with a new ECM, free of charge. The recall began on July 11, 2016. Owners may contact Cummins customer service at 1-800-343-7357 or Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1604.
Volvo Trucks North America (Volvo) is recalling certain 2016-2019 Volvo VNL trucks equipped with Cummins ISX15 diesel engines. In certain driving conditions, such as on a long down-hill grade, the fuel line may burst if the fuel pump cooling circuit screen becomes restricted.
If the fuel line bursts, fuel may leak onto the road resulting in a roadway hazard for other motorists. The engine may also stall without warning, resulting in the vehicle's inability to restart, increasing the risk of a crash.
Cummins will notify owners, and dealers will replace the single screen filter banjo bolt will be replaced with a dual screen filter banjo bolt, free of charge. The recall began November 21, 2018. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1802.
Mercedes-Benz USA, LLC - DBA Sprinter (Mercedes) is recalling certain model year 2014-2015 Sprinter 2500, and Sprinter 3500 vehicles manufactured February 28, 2014, to November 21, 2014. In the affected vehicles, oil may leak from around the chain tensioner gasket area.
Leaking oil may drip onto a hot engine surface, increasing the risk of a fire. Additionally, the leaking oil may be a road hazard for other vehicles, increasing the risk of a crash.
Mercedes will notify owners, and dealers will replace the chain tensioner gasket, free of charge. The recall began on December 19, 2014. Owners may contact Mercedes customer service at 1-877-762-8267. Mercedes' number for this recall is 2014120003.
Chrysler (FCA US LLC) is recalling certain 2013-2017 RAM 2500, 3500, 3500 Cab Chassis, 4500 Cab Chassis, and 5500 Cab Chassis vehicles, equipped with Cummins 6.7L Turbo Diesel engines that have Concentric-brand water pumps without a vent hole. These water pumps may leak coolant.
The leaking water pump can increase the risk of an engine compartment fire.
Chrysler will notify owners, and dealers will replace the water pumps, free of charge. The recall began February 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T51.
Chrysler (FCA US LLC) is recalling certain 2013-2017 RAM 2500, 3500, 3500 Cab Chassis, 4500 Cab Chassis, and 5500 Cab Chassis vehicles, equipped with Cummins 6.7L Turbo Diesel engines that have Concentric-brand water pumps without a vent hole. These water pumps may leak coolant.
The leaking water pump can increase the risk of an engine compartment fire.
Chrysler will notify owners, and dealers will replace the water pumps, free of charge. The recall began February 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T51.
We may earn a commission for purchases made through these links.
Also recalled in Canada