THE FLEXIBLE FUEL HOSE LOCATED BETWEEN THE INJECTOR FUEL RAIL AND THE FUEL PRESSURE REGULATOR MAY RUPTURE. THE HOSE MAY HAVE BEEN TURNED OUT OF ITS CORRECT POSITION WHEN BEING TIGHTENED DURING FINAL VEHICLE ASSEMBLY. A SHARP BEND OR TWIST IN THE HOSE NEAR ONE OF ITS END FITTINGS COULD LEAD TO HOSE RUPTURE WITH FUEL LEAKAGE CREATING A POSSIBLE FIRE HAZARD.
16 VALVE TURBO VEHICLES.
Safety Risk
No risk description available.
Remedy
No remedy description available.
269 vehicles affectedMfr ref: 7354Updated June 10, 2026
On certain vehicles, an unused wiring harness for a rear HVAC blower motor, located in the left B-pillar area, could become damaged if exposed to moisture or contaminants. If this happens, the wires could short circuit.
Note: This recall only affects cutaway chassis incomplete vehicles.
Safety Risk
A short circuit can create the risk of a fire.
Remedy
General Motors will notify owners by mail and instruct you to bring your vehicle to a dealership to seal the wiring for the rear HVAC blower motor at the left B-pillar.
25,587 vehicles affectedMfr ref: N222386050Updated June 10, 2026
THE FUEL TANK ATTACHMENT STRAP FASTENERS ARE BELOW THE SPECIFIED TORQUE.
THESE LOOSE FASTENERS COULD, IN TIME, BECOME COMPLETELY DETACHED. THIS COULD ALLOW THE FUEL TANK TO SAG DOWN TO THE POINT OF STRIKING SOMETHING IN THE ROAD OR THE ROAD SURFACE RESULTING IN A POSSIBLE FUEL LEAK AND AN UNDER-VEHICLE FIRE.
Safety Risk
No risk description available.
Remedy
FUEL TANK STRAP FASTENERS WILL BE TORQUED TO THE PROPER SPECIFICATIONS.
3,971 vehicles affectedMfr ref: 4D38/94081Updated June 10, 2026
THE FUEL SUPPLY, RETURN AND VAPOUR HOSES OR LINES MAY HAVE CONTACT OR INADEQUATE CLEARANCE WITH SURROUNDING COMPONENTS. THIS COULD CAUSE WEAR OF THE HOSE OR LINE AND RESULT IN A FUEL LEAK, WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD POTENTIALLY RESULT IN A FIRE.
Safety Risk
No risk description available.
Remedy
FUEL LINES THAT LACK ADEQUATE CLEARANCE WILL BE REPOSITIONED AND STEEL FUEL LINES WILL HAVE THE CORROSION PROTECTION REPAIRED AS APPROPRIATE.
3,173 vehicles affectedMfr ref: 94S93Updated June 10, 2026
On certain vehicles, a fuel injector may crack. If this happens, fuel could leak into the engine compartment.
Note: This recall only affects vehicles equipped with a 1.5 L EcoBoost engine. This recall is an expansion of Transport Canada recall number 2022-658.
Safety Risk
A fuel leak can create the risk of a fire.
Remedy
Ford will notify owners by mail and advise you to take your vehicle to a dealership to update the engine control software to detect fuel injector leaks. The dealer will also install a drain tube. Ford will also provide an extended warranty of 15 years/240 000 km to replace cracked injectors.
2,955 vehicles affectedMfr ref: 24S16Updated June 10, 2026
On certain vehicles, the side curtain airbag(s) may not have been manufactured properly. As a result, the airbag(s) may not inflate properly in a crash.
Safety Risk
A side curtain airbag that doesn't work properly could increase the risk of injury in a crash.
Remedy
FCA Canada will notify owners in writing and advise you to take your vehicle to a dealership to replace the side curtain airbag(s), as necessary.
78 vehicles affectedMfr ref: 82C,86C,87CUpdated June 10, 2026
On certain vehicles, the vent pipe inside the fuel tank may be damaged. As a result, gasoline could spill out of the filler neck when you remove the fuel cap.
Safety Risk
A fuel spill could create the risk of injury or a fire.
Remedy
Audi will notify owners by mail and instruct you to take your vehicle to a dealership to inspect the fuel tank vent pipe. If fuel spills out of the filler neck when the tank is pressurized, the dealer will replace the fuel tank and charcoal canister.
3,059 vehicles affectedMfr ref: 20DSUpdated June 10, 2026
Certain motorcyles do not comply with CMVSS 108 - Lighting System and Retroreflective Devices. Failure of one or more turn signal lamps would not be indicated to the operator of the vehicle by a noticeable change in the flashing rate of the turn signal indicator light.
Safety Risk
No risk description available.
Remedy
Turn signal flasher unit will be replaced.
150 vehicles affectedMfr ref: 0808Updated June 10, 2026
On certain trucks, when the manual override is used to switch off the daytime running lamps (DRLs), the lights may not turn on again when you start driving. Canadian regulations require that if DRLs are manually turned off, they must turn on again when you start driving.
Safety Risk
Driving without daytime running lights could make the vehicle less visible to others and increase the risk of a crash.
Remedy
Volvo Trucks will notify owners by mail and instruct you to take your truck to a dealer to update the vehicle software.
283 vehicles affectedMfr ref: RVXX2101Updated June 10, 2026
On certain vehicles, the exterior stainless-steel trim above the windshield may not be attached properly. As a result, the trim could loosen and detach from the vehicle.
Safety Risk
Trim that detaches from the vehicle could create a road hazard for others and increase the risk of a crash.
Remedy
Genesis will notify owners in writing and advise you to take your vehicle to a dealership to inspect and, if necessary, replace the exterior stainless-steel trim above the windshield.
1,239 vehicles affectedMfr ref: R0288Updated June 10, 2026
On certain vehicles, the compliance label has some small errors in translation. The French translation of the acronym for gross vehicle weight rating is misspelled as "PNBE", when it should be listed as "PNBV". Additionally, the French translation of the axle/tire position heading is misspelled as "Positionner". Canadian regulations require a company to use specific words on warning labels.
Safety Risk
These small errors do not affect safety.
Remedy
This is not a recall. Ineos has made changes to ensure that all new vehicles have the correct wording on the compliance label.
357 vehicles affectedMfr ref: 241803Updated June 10, 2026
On certain vehicles, a sound absorbing mat attached to the inside of the B-pillar side trim panel could have been improperly installed. The surface and edges of the mat could have been damaged during the assembly process. It could ignite when exposed to the exhaust gas of the seat belt pre-tensioner in the event of a severe front or side collision resulting in a vehicle fire
Safety Risk
No risk description available.
Remedy
Matting materials will be removed from inside the B-pillar on both sides of the vehicle.
4,583 vehicles affectedMfr ref: UFUpdated June 10, 2026
On certain vehicles, the passenger frontal airbag inflator could produce excessive internal pressure during airbag deployment. Increased pressure may cause the inflator to rupture, which could allow fragments to be propelled toward vehicle occupants, increasing the risk of injury. This could also damage the airbag module, which could prevent proper deployment. Failure of the passenger airbag to fully deploy during a crash (where deployment is warranted) could increase the risk of personal injury to the seat occupant.
Safety Risk
No risk description available.
Remedy
Dealers will replace the passenger side frontal airbag inflator with a new, non-ammonium-nitrate-based inflator.
6,367 vehicles affectedMfr ref: SR-17-004Updated June 10, 2026
On certain vehicles, a sealing cap at the fuel rail may fail to seal, allowing fuel to leak into the engine compartment during engine operation. Leaking fuel, in the presence of an ignition source, could lead to a fire causing injury and/or damage to property.
Safety Risk
No risk description available.
Remedy
Dealers will inspect, and if necessary, replace the fuel rail.
2,708 vehicles affectedMfr ref: 24BLUpdated June 10, 2026
On a small number of vehicles, the electronic stability program (ESP) control unit may have been damaged during assembly. As a result, water could leak into the control unit and cause a short circuit. If this happens, the vehicle stability control and antilock brake system (ABS) could turn off.
Safety Risk
A short circuit could create the risk of a fire. A loss of vehicle stability control and/or ABS could increase the risk of a crash.
Remedy
Mercedes-Benz will notify owners by mail and instruct you to take your vehicle to a dealership to replace the ESP control unit.
4 vehicles affectedMfr ref: 4290009Updated June 10, 2026
During servicing at a dealership, a small number of vehicles may have received an incorrect software update to one or more control units. As a result, the electronic stability control system, exterior lighting, and engine power could be affected.
Safety Risk
Safety systems that don't work correctly could increase the risk of a crash.
Remedy
Mercedes-Benz will notify owners by mail and instruct you to take your vehicle to a dealership to update the software in the control module(s).
5 vehicles affectedMfr ref: 5498725Updated June 10, 2026
On certain motorcycles, the side stand spring could break. If this happens, the side stand could fall or open suddenly while riding and cause the engine to stall.
Safety Risk
A sudden loss of engine power could increase the risk of a crash.
Remedy
KTM will notify owners by mail and advise you to take your motorcycle to a dealership to install a new side stand spring and sensor plate.
