Ohlins USA, Inc (Ohlins) is recalling certain Front Struts, part number POS 5N20. These struts were sold as part of Ohlins strut kits part number POZ MN02, intended for installation on 1999-2005 Porsche 911 Carrera 4 and 4S (generation 996), and 2001-2006 Porsche 911 Turbo / Turbo S (generation 996) and kit part number POZ MN05, intended for installation on 2005-2012 Porsche 911 Carrera 4 and 4S (generation 997), and 2006-2013 Porsche 911 Turbo / Turbo S (generation 997). The pin of the strut may experience excessive stress during maximum steering, possibly resulting breakage of the pin.
Safety Risk
If the pin fails, it will cause separation of the strut from the vehicle, affecting vehicle control and increasing the risk of a crash.
Remedy
Ohlins will notify owners, and dealers will request the return of all unsold kits containing the subject part from dealer/distributor inventory for a full refund. All owners who purchased one of the kits (POZ MN02 or POZ MN05) will receive replacement front struts (POS 5N20 or POS 5N21 - These parts are interchangeable), along with new top mount interface solutions, free of charge. The recall began December 22, 2020. Owners may contact Ohlins customer service at 1-800-336-9029.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The incorrect leaf spring shims may have been installed between the rear axle and the leaf springs possibly affecting the vehicle's handling. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Safety Risk
The incorrect leaf spring shims may negatively affect vehicle handling, increasing the risk of a crash.
Remedy
DVUSA will notify owners, and dealers will replace the leaf spring shims on both sides, renew the spring brackets, check the rubber buffers for wear, renewing them if necessary, and adjust the headlamps, free of charge. The manufacturer has not yet provided a schedule for recall notification. DVUSA issued owners an interim notification on September 18, 2020. The recall began October 1, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3LEFSPRI.
26 vehicles affectedMfr ref: VS3LEFSPRIUpdated June 10, 2026
On certain vehicles, the stabilizer link bracket on the left front strut may have been improperly welded during the manufacturing process. As a result, the bracket may detach from the strut and damage the tire and/or brake hose. Tire failure could cause the driver to lose vehicle control, whereas a damaged brake hose could cause a loss of brake fluid, which may increase stopping distances. Both issues could result in a crash causing property damage and/or personal injury.
Safety Risk
No risk description available.
Remedy
Dealers will inspect and, if necessary, replace the left front strut assembly.
62 vehicles affectedMfr ref: SR13-008Updated June 10, 2026
NOTE: INCOMPLETE CHASSIS-CABS.
ONE OR MORE OF THE SIX CLAMPS THAT HOLD THE TIRE AND RIM ASSEMBLY TO THE CAST SPOKES OF THE FRONT WHEEL MAY HAVE BEEN OF AN INCORRECT SIZE. INSTALLATION OF THE CLAMPS MAY RESULT IN BENDING OF THE STUDS WHICH ARE USED TO ATTACH THE CLAMPS TO THE SPOKES. THIS WOULD INCREASE THE RISK OF STUD FRACTURE AND POSSIBLE WHEEL FAILURE.
CORRECTION. STUDS AND CLAMPS WILL BE REPLACED ON AFFECTED VEHICLES.
Safety Risk
No risk description available.
Remedy
No remedy description available.
39 vehicles affectedMfr ref: 92S59Updated June 10, 2026
On certain vehicles, the rear suspension coil springs may not have been properly manufactured and could break over time. This could cause damage to a rear tire, resulting in rapid air loss and/or tire failure.
Safety Risk
A rear tire failure could affect vehicle control. Additionally, a broken coil spring could also create a road hazard for other motorists. Both of these conditions may increase the risk of a crash.
Remedy
The company will notify owners by mail. Owners will be instructed to take their vehicle to a dealer to have both of the rear axle coil springs replaced. If a broken coil spring is found, the rear tires should be inspected for damage and replaced as required.
15,579 vehicles affectedMfr ref: 42J5Updated June 10, 2026
ON CERTAIN MINIVANS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA. THE FRONT COIL SPRINGS COULD FRACTURE AS A RESULT OF CORROSION. DEPENDING ON THE LOCATION OF THE FRACTURE, A BROKEN SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.
Safety Risk
SOME TIRES HAVE DEFLATED DUE TO CONTACT WITH A BROKEN SPRING.
Remedy
DEALERS WILL INSTALL PROTECTIVE SHIELDS AROUND THE FRONT COIL SPRINGS. OWNER NOTIFICATION BEGAN SEPTEMBER 6, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
On certain motorcycles, the mounting bracket for the rear shock absorber adjuster could break. If this happens, the shock absorber adjuster could move and damage the rear tire. This could lead to a sudden loss of air pressure and a tire failure.
Note: Motorcycles that were repaired under recall 0181 (Transport Canada recall no. 2023-473) also require this repair.
Safety Risk
A tire failure could cause a loss of control and increase the risk of a crash.
Remedy
Harley-Davidson will notify owners by mail and advise you to take your motorcycle to a dealership to replace the rear shock mounting bracket.
5,304 vehicles affectedMfr ref: 0188Updated June 10, 2026
VEHICLE DESCRIPTION: HEAVY DUTY 6X4 TRUCKS EQUIPPED WITH CHALMERS 800 SERIES SUSPENSION KITS. THESE SUSPENSION KITS MAY HAVE INSUFFICIENT PENETRATION OF THE WELD ATTACHING THE TORQUE ROD EYE TO THE TORQUE ROD TUBE.
Safety Risk
FAILURE OF THE WELD COULD RESULT IN SEPARATION OF THE EYE AND TUBE, CAUSING A LOCK OF AXLE RETENTION, WHICH COULD RESULT IN LOSS OF VEHICLE CONTROL.
Remedy
DEALERS WILL REPLACE ALL CHALMERS FIXED TORQUE RODS ON THESE VEHICLES. CHALMERS IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHALMERS AT 1-905-624-9750.
On certain vehicles, road de-icing salt used during winter months may result in corrosion of the lower plate or the front lower control arm. Corrosion may proceed to the point where the lower plate becomes perforated and the front lower control arm fractures between its forward and rearward pivot attachments to the chassis. If the front lower control arm fractures, the wheel assembly may be allowed to move rearward in the wheel well opening during braking. Reduced control of the front wheel location may increase the risk of a vehicle crash.
Safety Risk
No risk description available.
Remedy
Dealer will replace the front lower control arm.
24,211 vehicles affectedMfr ref: R36Updated June 10, 2026
Note: vehicles located in Ontario, Quebec, New Brunswick, Nova Scotia, Prince Edward Island and Newfoundland. Continuous exposure to road salt and chemicals may cause corrosion of the rear suspension inner arms which could affect the operation and control of the vehicle.
Safety Risk
No risk description available.
Remedy
Inner arms of the rear suspension will be inspected and rust proofed or replaced.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and RAV4 Hybrid vehicles. The front lower suspension arms may have cracks, which may result in the suspension arm separating from the front wheel assembly.
Safety Risk
If a suspension control arm breaks, it can result in a loss of vehicle control, increasing the risk of a crash.
Remedy
Toyota will notify owners, and dealers will replace both front lower suspension arms, free of charge. This recall began August 10, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's interim numbers for this recall are 20TB08 / 20TA08.
9,502 vehicles affectedMfr ref: 20TB08 / 20TA08Updated June 10, 2026
On certain vehicles, the front wheel spindle nut - which retains the hub, rotor, and wheel assembly - may have been omitted during vehicle assembly. This could allow the wheel assembly to separate from the vehicle while driving, which could result in a vehicle crash causing property damage, personal injury or death.
Safety Risk
No risk description available.
Remedy
Dealers will inspect for presence of the front wheel spindle nut, and repair any vehicle missing the nut.
1,172 vehicles affectedMfr ref: J27Updated June 10, 2026
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, THE FRONT COIL SPRINGS COULD FRACTURE DUE TO CORROSION ASSOCIATED WITH SALT USED ON THE ROADWAYS DURING THE WINTER. A FRACTURED SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.
Safety Risk
IF THIS OCCURS, THE TIRE MAY RUPTURE RESULTING IN A RAPID AIR LOSS, WHICH COULD RESULT IN A CRASH.
Remedy
DEALERS WILL INSTALL PROTECTIVE SPRING SHIELDS. IN ADDITION, FORD IS EXTENDING THE WARRANTY COVERAGE OF THE FRONT COIL SPRINGS IN ALL OTHER STATES, FOR FRACTURE ONLY, UP TO 10 YEARS OF SERVICE OR 150,000 MILES, WHICHEVER OCCURS FIRST. IF THE VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2005. IF EITHER FRONT COIL SPRING FRACTURES, DEALERS WILL REPLACE BOTH FRONT SPRINGS AT NO CHARGE TO THE OWNER. AN INTERIM NOTICE WAS SENT TO OWNERS ON AUGUST 2, 2004. PARTS ARE NOW AVAILABLE FOR THE 2000-2001 MY VEHICLES AND OWNERS WERE SENT A LETTER ON JANUARY 10, 2005, ADVISING THEM TO BRING IN THEIR VEHICLES FOR REPAIR PARTS ARE EXPECTED TO BE AVAILABLE FOR THE 1999 MY VEHICLES BY THE END OF FEBRUARY 2005 AND OWNERS OF THESE VEHICLES WILL BE NOTIFIED THEN. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
ON CERTAIN PASSENGER VEHICLES, DURING THE STRUT MOUNT MANUFACTURING PROCESS, THE THRUST BEARING WAS NOT PROPERLY POSITIONS AND SECURED. IF THE SUSPENSION IS FULLY UNLOADED, THE FRONT STRUT COULD SEPARATE FROM THE UPPER MOUNT.
Safety Risk
THIS COULD AFFECT VEHICLE HANDLING AND CONTROL, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL REPLACE BOTH FRONT SPRING STRUT UPPER MOUNTS. OWNER NOTIFICATION BEGAN MARCH 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
On certain vehicles, the rear-axle anti-roll bar connecting links could wear prematurely and cause a link to detach. A detached link could come in contact with other suspension parts and cause damage, which may affect vehicle handling and increase the risk of a crash causing injury and/or damage to property.
Safety Risk
No risk description available.
Remedy
Dealers will replace the real-axle anti-roll bar connecting links.
80 vehicles affectedMfr ref: AJ06Updated June 10, 2026
BMW is recalling certain model year 2013 R1200 GS motorcycles manufactured January 9, 2013, through February 8, 2013. Due to an insufficient torque of a locking bolt, the front fork tube may loosen.
Safety Risk
If the fork loosens it may hinder the rider's ability to control the motorcycle, increasing the risk of a crash.
Remedy
BMW will notify owners and dealers will reinforce the affected fork locking bolt connections, free of charge. Owners were notified of the safety recall by telephone on April 22 and April 23, 2013. Therefore, an owner notification letter will not be issued for this campaign. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Chrysler (FCA US, LLC) is recalling certain 2022-2023 Jeep Grand Cherokee and 2021-2023 Jeep Grand Cherokee L vehicles. The rear coil springs may have been incorrectly installed and detach from the vehicle while driving.
Safety Risk
Rear coil springs that detach from the vehicle while driving increases the risk of a crash.
Remedy
Dealers will inspect and if necessary, repair the rear coil spring assemblies, free of charge. Owner notification letters were mailed June 29, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 64A. This recall is replaced by NHTSA recall 26V051. All vehicles will need to have the new recall remedy performed.
305,282 vehicles affectedMfr ref: 64AUpdated June 10, 2026
Chrysler (FCA US, LLC) is recalling certain 2022-2023 Jeep Grand Cherokee and 2021-2023 Jeep Grand Cherokee L vehicles. The rear coil springs may have been incorrectly installed and detach from the vehicle while driving.
Safety Risk
Rear coil springs that detach from the vehicle while driving increases the risk of a crash.
Remedy
Dealers will inspect and if necessary, repair the rear coil spring assemblies, free of charge. Owner notification letters were mailed June 29, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 64A. This recall is replaced by NHTSA recall 26V051. All vehicles will need to have the new recall remedy performed.
305,282 vehicles affectedMfr ref: 64AUpdated June 10, 2026
THESE VEHICLES MAY HAVE BEEN BUILT WITH WELDS OMITTED FROM THE FRONT SUSPENSION LOWER CONTROL ARM ASSEMBLIES. THIS CONDITION COULD CAUSE EXCESSIVE LOADS ON EXISTING CONTROL ARM WELDS, AND COULD RESULT IN SEPARATION OF THE FRONT BUSHING-SLEEVE SUBASSEMBLY FROM THE CONTROL ARM. THIS COULD RESULT IN REDUCED STEERING CONTROL AND A CRASH WITHOUT PRIOR WARNING.
Safety Risk
No risk description available.
Remedy
SUSPENSION LOWER CONTROL ARMS WILL BE INSPECTED AND THOSE FOUND WITH OMITTED WELDS WILL BE REPLACED.
11,971 vehicles affectedMfr ref: 5D04/95008Updated June 10, 2026
Ford Motor Company (Ford) is recalling certain 2021 Mustang Mach-E vehicles. The front subframe bolts may not have been tightened properly during assembly, which could result in loose bolts.
Safety Risk
Loose subframe bolts may reduce the vehicle's performance in a crash, increasing the risk of injury.
Remedy
Ford will notify owners, and dealers will inspect the front subframe bolts and tighten them as necessary, free of charge. The recall began April 2, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S09.
1,258 vehicles affectedMfr ref: 21S09Updated June 10, 2026
