VEHICLE DESCRIPTION: SOME 4X2 SPORT UTILITY VEHICLES NOT EQUIPPED WITH AN ANTILOCK BRAKING SYSTEM MAY HAVE INADVERTENTLY BEEN BUILT WITH 4X4 REAR HUBS INSTEAD OF 4X2 HUBS. IF THE INCORRECT HUBS ARE INSTALLED ON A 4X2 VEHICLE, THE REAR WHEELS CAN LOOSEN, OR IN SOME CASES, SEPARATE FROM THE VEHICLE.
Safety Risk
THIS CONDITION COULD CAUSE LOSS OF CONTROL OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL INSPECT THE REAR HUBS AND, IF NECESSARY, REPLACE THEM. OWNER NOTIFICATION BEGAN SEPTEMBER 25, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
ON CERTAIN VEHICLES, THE RIGHT FRONT STEERING KNUCKLE MAY HAVE BEEN IMPROPERLY MANUFACTURED. BECAUSE OF A BROKEN COOLING LINE, PARTS CAST IN TOOL CAVITY #63 ON JULY 18 AND JULY 19, 2006, MAY HAVE A COLD SHUT CONDITION AND COULD FRACTURE.
Safety Risk
THIS COULD CAUSE A LOSS OF STEERING CONTROL AND RESULT IN A CRASH WITHOUT WARNING.
Remedy
DEALERS WILL INSPECT THE RECALLED VEHICLES TO IDENTIFY THE DEFECTIVE PARTS AND REPLACE IF THEY ARE WITHIN THAT LOT. THE RECALL BEGAN ON NOVEMBER 8, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
On certain vehicles, the wiring under the front seats of vehicles equipped with power seats could be misrouted, allowing the wire to be pinched by metal seat components. As a result, electrical resistance will trip a circuit breaker diode in the fuse junction box. After the diode cools down, it will reset and recycle through this process repeatedly. It may be possible for the diode to continue to build up heat instead of cooling down, which may result in a fire in another component in the junction box area.
Safety Risk
No risk description available.
Remedy
Dealers will inspect to confirm the integrity of the power seat wiring. In addition, the dealer will install corrugated tubing around the underseat wires to eliminate the possibility of wire pinching.
9,220 vehicles affectedMfr ref: R19Updated June 10, 2026
THE NUTS AND BOLTS THAT ATTACH THE REAR BRAKE ADAPTOR TO THE AXLE HOUSING FLANGE CAN LOOSEN AND EVENTUALLY SEPARATE. IF ONE OR MORE OF THE NUTS COME OFF THE BOLTS, DAMAGE TO THE PARKING BRAKE ASSEMBLY OR TO THE ANTILOCK BRAKE SYSTEM (ABS) SENSOR AND SENSOR RING (IF SO EQUIPPED) WILL OCCUR. IF ALL FOUR NUTS ON ONE END OF THE AXLE COME OFF THE BOLTS, DAMAGE TO THE BRAKE HYDRAULIC LINE OR THE PARKING BRAKE CABLE CAN OCCUR.
Safety Risk
OCCURRENCE OF ANY OF THESE CONDITIONS CAN RESULT IN A LOSS OF BRAKING CAPABILITY AND POSSIBLE ACCIDENT.
Remedy
DEALERS WILL INSPECT AND, IF NEEDED, INSTALL NEW BOLTS. IF ANY OF THE FASTENERS ARE DISCONNECTED, THE PARKING BRAKE AND ABS COMPONENTS WILL BE INSPECTED AND SERVICED.
Kia Motors America (Kia) is recalling certain 2014-2016 Soul and Soul EV vehicles. The pinion plug may allow the pinion gear to separate from the steering gear assembly.
Safety Risk
If the pinion gear separates, steering will be lost, increasing the risk of a crash.
Remedy
Kia will notify owners, and dealers will inspect and secure the pinion plug or replace the steering gear assembly, as necessary, free of charge. The recall began November 16, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC155. Note: This recall supersedes campaigns 14V-332 and 15V-736. Vehicles previously remedied under those numbers are being recalled again under this campaign.
342,381 vehicles affectedMfr ref: SC155Updated June 10, 2026
IMPROPERLY TORQUED TIE ROD CLAMP FASTENERS COULD ALLOW THE TIE ROD TO LOOSEN AND EVENTUALLY SEPARATE.
Safety Risk
IF TIE ROD SEPARATES AND AFFECTED WHEEL HITS A HUMP OR IS SUBJECTED TO MODERATE TO HEAVY BRAKING FORCES, THIS COULD RESULT IN LOSS OFSTEERING CONTROL AND A VEHICLE CRASH.
Remedy
PROPERLY TORQUE TIE ROD CLAMPS AND RE-ADJUST TOE-IN AS NECESSARY.
ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS EQUIPPED WITH ACCURIDE ALUMINUM WHEELS, THE WHEELS WERE NOT PROPERLY PRE-STRESSED. THIS ALLOWS CRACKS TO DEVELOP OVER TIME.
Safety Risk
THIS MAY EVENTUALLY LEAD TO WHEEL FAILURE AND POSSIBLY RESULT IN A VEHICLE CRASH.
Remedy
DEALERS WILL REPLACE THE WHEELS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 30, 2005 OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
THE WHEEL LUG NUTS ON THE ROAD WHEELS MAY BECOME LOOSE. IF THE NUTS BEGIN TO LOOSEN, THE VEHICLE MAY BEGIN TO VIBRATE WHICH COULD ADVERSELY AFFECT HANDLING STABILITY.
Safety Risk
No risk description available.
Remedy
VEHICLES WILL BE INSPECTED AND ROAD WHEELS REPLACED IF NECESSARY.
4 vehicles affectedMfr ref: 95V186Updated June 10, 2026
On certain vehicles, the double check valve disc incorporated into the brake manifold dash valve can become brittle over time and crack. If this condition exists and there is a single point failure in either the primary or secondary air system, loss of all service braking could result without warning with the potential for a vehicle crash.
Safety Risk
No risk description available.
Remedy
Manifold dash valve will be replaced.
2,160 vehicles affectedMfr ref: RVXX0002Updated June 10, 2026
ON CERTAIN PASSENGER VEHICLES, THE THROTTLE PEDAL ASSEMBLY CAN BECOME DISPLACED FROM ITS HOUSING.
Safety Risk
A DRIVER COULD EXPERIENCE LOSS OF THROTTLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL INSPECT AND REPLACE, IF NECESSARY, THE THROTTLE PEDALS. THE RECALL BEGAN ON DECEMBER 23, 2004. OWNERS SHOULD CONTACT ASTON MARTIN AT 201-818-8352.
On certain vehicles equipped with the 2.0l engine coupled to a 6 speed automatic transmission, the torque converter could separate from the engine flex plate due to inadequate welds on the attachment studs. If this occurs, this would result in a sudden loss of motive power, increasing the risk of a crash causing injury and/or damage to property.
Safety Risk
No risk description available.
Remedy
Dealers will replace the torque converter.
2 vehicles affectedMfr ref: 17S16Updated June 10, 2026
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine. The engine intake valves may break while driving, which can result in engine failure and a loss of drive power.
Safety Risk
A loss of drive power increases the risk of a crash.
Remedy
Dealers will perform an engine cycle test and replace the engine as necessary, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S55.
90,736 vehicles affectedMfr ref: 24S55Updated June 10, 2026
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine. The engine intake valves may break while driving, which can result in engine failure and a loss of drive power.
Safety Risk
A loss of drive power increases the risk of a crash.
Remedy
Dealers will perform an engine cycle test and replace the engine as necessary, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S55.
90,736 vehicles affectedMfr ref: 24S55Updated June 10, 2026
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine. The engine intake valves may break while driving, which can result in engine failure and a loss of drive power.
Safety Risk
A loss of drive power increases the risk of a crash.
Remedy
Dealers will perform an engine cycle test and replace the engine as necessary, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S55.
90,736 vehicles affectedMfr ref: 24S55Updated June 10, 2026
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine. The engine intake valves may break while driving, which can result in engine failure and a loss of drive power.
Safety Risk
A loss of drive power increases the risk of a crash.
Remedy
Dealers will perform an engine cycle test and replace the engine as necessary, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S55.
90,736 vehicles affectedMfr ref: 24S55Updated June 10, 2026
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine. The engine intake valves may break while driving, which can result in engine failure and a loss of drive power.
Safety Risk
A loss of drive power increases the risk of a crash.
Remedy
Dealers will perform an engine cycle test and replace the engine as necessary, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S55.
90,736 vehicles affectedMfr ref: 24S55Updated June 10, 2026
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine. The engine intake valves may break while driving, which can result in engine failure and a loss of drive power.
Safety Risk
A loss of drive power increases the risk of a crash.
Remedy
Dealers will perform an engine cycle test and replace the engine as necessary, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S55.
90,736 vehicles affectedMfr ref: 24S55Updated June 10, 2026
LIGHT TRUCKS WITH 5 LITRE ENGINES AND ELECTRONIC FUEL INJECTION. BURRS AND/OR SHARP EDGES MAY BE PRESENT ON THE FUEL RAILS AT THE PUSH CONNECT FITTING OF EITHER THE SUPPLY OR RETURN LINE ASSEMBLIES. THESE BURRS OR SHARP EDGES MAY HAVE DAMAGED THE O-RING SEALS IN THE PUSH CONNECT FITTING. THIS COULD RESULT IN FUEL LEAKAGE WHEN THE ENGINE IS STARTED PRESENTING THE POTENTIAL FOR AN ENGINE COMPARTMENT FIRE.
Safety Risk
No risk description available.
Remedy
No remedy description available.
46 vehicles affectedMfr ref: S4DUpdated June 10, 2026
Chrysler (FCA US, LLC) is recalling certain 2021-2023 Jeep Wrangler Plug-In Hybrid Electric (PHEV) vehicles. The high voltage battery may fail internally and lead to a vehicle fire while parked or driving.
Safety Risk
A vehicle fire while parked or driving can increase the risk of injury.
Remedy
Owners are advised not to recharge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack software and replace the battery pack assembly if necessary, free of charge. Owner notification letters were mailed March 7, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 89A. This recall is superseded by NHTSA Recall 24V-720.
32,125 vehicles affectedMfr ref: B9AUpdated June 10, 2026
On certain vehicles equipped with a dealer-installed accessory remote engine starter, if the fob is dropped, movement of the internal battery retaining clip may occur and cause damage to a component on the printed circuit board. Under this condition, the fob may transmit an engine start (or stop) request without the user pressing the button. If the vehicle is in range and receives the request, the engine may start and run for up to 15 minutes (or until a stop request is received). The engine may continue to start and stop until the fob battery is depleted, or until the vehicle runs out of fuel. If that occurs when the vehicle is parked in an enclosed area, such as a garage, there is a risk of carbon monoxide build-up, which could result in asphyxiation or carbon monoxide poisoning.
Safety Risk
No risk description available.
Remedy
Dealers will replace the remote engine starter fob.
2,813 vehicles affectedMfr ref: WQF-42Updated June 10, 2026
Also recalled in Canada