On certain vehicles, the transmission wiring harness may be too short. As a result, the wiring could be damaged by contact with the front driveshaft. If this happens, there could be a loss of power to the wheels.
Note: This recall only affects certain AMG E 53 hybrid models.
Safety Risk
A loss of power to the wheels could increase the risk of a crash.
Remedy
Mercedes-Benz will notify owners by mail and advise you to take your vehicle to a dealership to inspect the transmission wiring harness and re-route it if necessary.
41 vehicles affectedMfr ref: 5491322Updated June 10, 2026
A BOLT THAT SECURES A FUEL LINE SHIELD TO THE LOWER PORTION OF THE DASH PANEL PROTRUDES THROUGH THE PANEL AND MAY INTERFERE WITH THE ACCELERATOR PEDAL WHEN THE PEDAL IS FULLY DEPRESSED. UNDER CERTAIN CIRCUMSTANCES, THIS COULD RESULT IN THE PEDAL STICKING AT THE WIDE OPEN THROTTLE POSITION. THIS COULD CAUSE POSSIBLE LOSS OF CONTROL AND A VEHICLE CRASH.
Safety Risk
No risk description available.
Remedy
BOLT WILL BE CUT OFF FLUSH WITH THE TOP OF THE WELD NUT THROUGH WHICH IT PROTRUDES.
560 vehicles affectedMfr ref: 90S06Updated June 10, 2026
On certain vehicles, the nuts securing the propeller shaft to the rear differential may have not been tightened to specification during assembly and could loosen over time. This could cause the propeller shaft to come loose from the rear differential, which would result in excessive noise and may contact and eventually damage the fuel tank, which may result in a fuel leak. Fuel leakage, in the presence of an ignition source, could result in a fire causing injury and/or property damage.
Safety Risk
No risk description available.
Remedy
Dealers will inspect the nuts fastening the propeller shaft to the rear differential and tighten or replace the nuts and bolts as necessary.
185 vehicles affectedMfr ref: WQV-57Updated June 10, 2026
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH 4-WHEEL DRIVE. THE CALIBRATION OF THE TRANSFER CASE CONTROL MODULE COULD CAUSE INSUFFICIENT HIGH SPEED GEAR ENGAGEMENT.
Safety Risk
IF THE GEAR IS NOT ENGAGED, THE VEHICLE CAN ROLL WHEN THE TRANSMISSION IS IN "PARK" AND A CRASH COULD RESULT WITHOUT WARNING.
Remedy
DEALERS WILL UPDATE THE TRANSFER CASE CONTROL MODULE CALIBRATION TO INCREASE GEAR ENGAGEMENT. OWNER NOTIFICATION BEGAN NOVEMBER 6, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
On certain vehicles, the driver's airbag inflator could produce excessive internal pressure. If an affected airbag deploys, the increased internal pressure may cause the inflator to rupture and metal fragments could pass through the airbag cushion material and cause injury to vehicle occupants.
Safety Risk
No risk description available.
Remedy
Dealers will replace airbag inflator.
91,447 vehicles affectedMfr ref: AK25, AK26Updated June 10, 2026
On certain vehicles, primer may not have been applied during installation of the panoramic glass roof. Reduced adhesion could allow the glass roof to completely detach from the vehicle, possibly striking another vehicle, a stationary object, or a bystander, causing property damage and/or personal injury.
Safety Risk
No risk description available.
Remedy
Dealers will inspect and, if necessary, remove and correctly reinstall the panoramic glass roof.
1,409 vehicles affectedMfr ref: SR13-007Updated June 10, 2026
On certain vehicles, there could be a problem inside the high-voltage battery. As a result, the battery modules could overheat and short circuit.
Safety Risk
A short circuit in the high-voltage battery can create a fire risk.
Remedy
To reduce the safety risk, Mercedes-Benz recommends that you set the maximum charge setting of your vehicle at 80% until the recall repairs are completed. Mercedes-Benz will notify owners by mail and advise you to take your vehicle to a dealership to update the battery management system software.
632 vehicles affectedMfr ref: 5496507Updated June 10, 2026
On certain vehicles, if operated at low speeds in a hot and humid environment with the window open, air conditioner running and audio on, condensed water on the A/C duct surface may drop and enter into the audio unit, causing a short circuit. If the short circuit occurs at one specific set of terminals, the rear right speaker can overheat and possibly catch fire.
Safety Risk
No risk description available.
Remedy
Dealers will affix aluminum tape over the audio unit to prevent water from entering .
4,205 vehicles affectedMfr ref: 98011Updated June 10, 2026
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2020-2021 GLE350, GLE450, GLS450, GLS580, 2021 AMG GLE53, AMG GLE63, Maybach GLS600, AMG GLS63, and 2020 GLE580 vehicles. The air conditioner drain hoses may have been incorrectly installed, causing water to drain into the passenger compartment.
Safety Risk
Water intrusion into the foot wells may cause corrosion and/or short circuits to electrical components, increasing the risk of fire. In addition, the emergency call (eCall) feature may be disabled and the doors may not unlock, increasing the risk of injury. Also, the engine may not start or may enter a limp-home mode, increasing the risk of a crash.
Remedy
Dealers will inspect and reinstall the air conditioner drain hoses, as necessary, free of charge. Owner notification letters were mailed April 28, 2023. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of recall numbers 21V-288 and 19V-587. MBUSA's numbers for this recall are 2023030014 and 15.
61,450 vehicles affectedMfr ref: 2023030014 & 15Updated June 10, 2026
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2020-2021 GLE350, GLE450, GLS450, GLS580, 2021 AMG GLE53, AMG GLE63, Maybach GLS600, AMG GLS63, and 2020 GLE580 vehicles. The air conditioner drain hoses may have been incorrectly installed, causing water to drain into the passenger compartment.
Safety Risk
Water intrusion into the foot wells may cause corrosion and/or short circuits to electrical components, increasing the risk of fire. In addition, the emergency call (eCall) feature may be disabled and the doors may not unlock, increasing the risk of injury. Also, the engine may not start or may enter a limp-home mode, increasing the risk of a crash.
Remedy
Dealers will inspect and reinstall the air conditioner drain hoses, as necessary, free of charge. Owner notification letters were mailed April 28, 2023. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of recall numbers 21V-288 and 19V-587. MBUSA's numbers for this recall are 2023030014 and 15.
61,450 vehicles affectedMfr ref: 2023030014 & 15Updated June 10, 2026
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2020-2021 GLE350, GLE450, GLS450, GLS580, 2021 AMG GLE53, AMG GLE63, Maybach GLS600, AMG GLS63, and 2020 GLE580 vehicles. The air conditioner drain hoses may have been incorrectly installed, causing water to drain into the passenger compartment.
Safety Risk
Water intrusion into the foot wells may cause corrosion and/or short circuits to electrical components, increasing the risk of fire. In addition, the emergency call (eCall) feature may be disabled and the doors may not unlock, increasing the risk of injury. Also, the engine may not start or may enter a limp-home mode, increasing the risk of a crash.
Remedy
Dealers will inspect and reinstall the air conditioner drain hoses, as necessary, free of charge. Owner notification letters were mailed April 28, 2023. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of recall numbers 21V-288 and 19V-587. MBUSA's numbers for this recall are 2023030014 and 15.
61,450 vehicles affectedMfr ref: 2023030014 & 15Updated June 10, 2026
On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, could eventually degrade the propellant contained in the passenger frontal airbag. This could cause the airbag to deploy with more force than normal. As a result, if the vehicle were involved in a collision that warrants airbag deployment, fragments could be propelled toward vehicle occupants, and the airbag assembly could be damaged, preventing proper function. These issues could increase the risk of injury.
Safety Risk
No risk description available.
Remedy
Dealers will replace the passenger frontal airbag inflator.
25,303 vehicles affectedMfr ref: TKC-17Updated June 10, 2026
On certain vehicles equipped with Caterpillar C7 and C9 diesel engines, fuel pump failure can dilute the engine oil with fuel and cause the turbocharger to fail, leading to a loss of throttle control and excessive smoke. Either condition could result in a vehicle crash causing property damage, personal injury or death.
Safety Risk
No risk description available.
Remedy
Authorized Caterpillar dealers will replace the fuel pump.
17 vehicles affectedMfr ref: 07V11Updated June 10, 2026
On certain vehicles located in Manitoba, Ontario, Quebec, New Brunswick, Nova Scotia, Prince Edward Island, and Newfoundland & Labrador, the lower sub frame mount plate nut may corrode and fail due to exposure to road salt. This could result in loss of structural integrity of the subframe mount attachment. Detachment of the body mounts at the rear corners of the sub frame which supports the engine and transmission, allows the rear corners of the sub frame to drop. Should both rear corners drop, steering control would be adversely affected.
Safety Risk
No risk description available.
Remedy
Dealers will install subframe rear mount bolts, reinforcement plate and plate nuts.
251,032 vehicles affectedMfr ref: 98S36Updated June 10, 2026
On certain vehicles, the recall repairs completed by an FCA dealer during recall 95B (Transport Canada recall no. 2024-566) may not be effective. As a result, another repair is required.
On certain vehicles, there could be a problem inside the high-voltage battery that can cause a fire, even while parked with the ignition off.
Note: This recall only affects 4xe plug-in hybrid (PHEV) models. This recall replaces Transport Canada recall no. 2024-566.
Safety Risk
The vehicle could catch fire, even while parked and turned off.
Remedy
To reduce the safety risk, FCA advises not to charge your vehicle, and to park it outdoors and away from other vehicles or structures until the recall repairs have been completed. FCA Canada will notify owners in writing and advise you to take your vehicle to a dealership to update the high-voltage battery pack software. If necessary, the battery pack will be replaced.
20,753 vehicles affectedMfr ref: 68CUpdated June 10, 2026
VEHICLE DESCRIPTION: ON CERTAIN VANS WITH AMBULANCE PREP PACKAGES OR OTHER SEVERE-DUTY APPLICATIONS INVOLVING OPERATION AT OR NEAR THE GROSS VEHICLE WEIGHT WITH FREQUENT TWISTING OF THE VEHICLE BODY, SUCH AS OFF-ROAD, ROUGH ROAD OR SPEED BUMP EVENTS, THE 35 GALLON MID-SHIP FUEL TANK COULD DEVELOP A CRACK WHERE IT CONTACTS THE FRAME CROSS MEMBER. IF THE FUEL TANK CRACKS, FUEL LEAKAGE COULD OCCUR.
Safety Risk
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy
DEALERS WILL INSPECT THE FUEL TANK AND, IF CRACKED, WILL REPLACE THE TANK. INSULATOR PADS WILL BE INSTALLED ON ALL VEHICLES TO REDUCE THE STRESS LEVELS IN THE FUEL TANK. OWNER NOTIFICATION BEGAN APRIL 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
IF LIQUID IS SPILLED IN THE CONSOLE BOX AREA, THE AIR BAG WARNING LIGHT CAN ILLUMINATE AND STAY "ON" DURING NORMAL DRIVING CONDITIONS.
Safety Risk
THIS LEAKAGE CONDITION COULD CAUSE THE AIR BAG TO INADVERTENTLY DEPLOY.
Remedy
DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE AIR BAG SENSOR TO PREVENT POSSIBLE MALFUNCTION CAUSED BY THE SPILLING OF LIQUID SUBSTANCES ON THE SENSOR. AIR BAG SENSORS DAMAGED BY PREVIOUS LIQUID SPILLAGE WILL BE REPLACED.
A CRACKING CONDITION COULD DEVELOP IN THE SEVEN SPOKE FRONT AND REAR CAST WHEELS. IF NOT DETECTED, THESE CRACKS COULD PROPOGATE THROUGH THE SPOKES AND CAUSE THE WHEEL HUB AND RIM TO SEPARATE WITHOUT PRIOR WARNING. THIS COULD RESULT IN LOSS OF VEHICLE CONTROL AND A CRASH WITHOUT PRIOR WARNING.
Safety Risk
No risk description available.
Remedy
WHEELS WILL BE REPLACED WITH WHEELS OF A DIFFERENT TESTED DESIGN.
654 vehicles affectedMfr ref: 062Updated June 10, 2026
BRACKETS CONNECTING THE FRONT SUSPENSION ARMS TO THE SUPPORTING SUB-FRAME MAY NOT HAVE BEEN COMPLETELY WELDED TO THE SUB-FRAME. IF THE BRACKETS SEPARATE VEHICLE HANDLING WILL BE IMPAIRED WITH THE POSSIBILITY OF A VEHICLE CRASH WITHOUT PRIOR WARNING TO THE DRIVER.
